LEMON Manuals: Even more car manuals for everyone
Home >> Jeep >> 2005 >> Wrangler Rubicon, Standard >> Repair and Diagnosis >> External Pages >> Different car >> Section 562 (HVAC Systems (Service Information)) >> Distribution >> Ducts-Floor Distribution >> Removal >> Rear Floor Ducts

Rear Floor Ducts

WARNING: This page is about a different car, the 2005 Jeep Grand Cherokee. However, it is still accessible from the selected car via links, so may be relevant.
Fig 1: Front Console Duct
GC0028322Courtesy of DAIMLERCHRYSLER CORP.
  1. Remove the floor console from the passenger compartment (Refer to BODY/INTERIOR/FLOOR CONSOLE - REMOVAL) .
  2. Remove the front seats (Refer to BODY/SEATS/SEAT - REMOVAL) .
  3. Disengage the push-pin retainer (1) that secures the front console duct (2) to the gear selector (3).
  4. Disconnect the front console duct from the air distribution housing (4) and remove the console duct.
  5. Remove the screws (5) that secure the gear selector to the floor panel (6) and position the gear selector out of the way.
    Fig 2: Floor Distribution Duct
    GC0028323Courtesy of DAIMLERCHRYSLER CORP.
  6. Roll back the front floor carpet from under the instrument panel toward the rear of the vehicle (Refer to BODY/INTERIOR/CARPETS AND FLOOR MATS - REMOVAL) .
  7. Disconnect the left rear floor duct (1) and the right rear floor duct (2) from the rear floor distribution duct (3).
  8. Disengage the retainer that secures the rear floor ducts to the floor support and remove the floor ducts.
  9. Disconnect the rear floor distribution duct from the air distribution housing (4) and remove the distribution duct.
scientia non olet · About LEMON Manuals