LEMON Manuals: Even more car manuals for everyone
Home >> Jaguar >> 2021 >> F-Pace SVR >> Repair and Diagnosis >> Transmission >> Manual Trans >> Transfer Case - Vehicles With: 6S45 6-Speed Manual Transmission RWD/6S45 6-Speed Manual Transmission AWD -- F-Pace (X761) >> Transfer Case - Vehicles With: 6S45 6-Speed Manual Transmission AWD/6S45 6-Speed Manual Transmission RWD (G1904679) >> Removal And Installation >> Transfer Case Bush (G2011755) >> Installation

Transfer Case Bush (G2011755): Installation

  1. CAUTION: Make sure the special tool is installed to the bush in the correct orientation.
    G11314305Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Special Tool(s): JLR-307-698 

  2. NOTE: To aid installation, lubricate the bush with soapy water.
    G11314306Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Using the special tools, install the transfer case bush half way into the transfer case and wait for 2 minutes.

    Special Tool(s): JLR-307-698 

  3. G11314307Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Fully install the transfer case bush into the transfer case and wait for 2 minutes.

    Special Tool(s): JLR-307-698 

  4. G11314308Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Release the special tools and wait for 2 minutes. Check that the bush is evenly installed with no more than a 1 mm gap between the faces of the bush and the transfer case. If the gap is more than 1 mm repeat installation step  3.

    Special Tool(s): JLR-307-698 

  5. Install the transfer case.

    Refer to: TRANSFER CASE .

  6. Connect the battery ground cable.

    Refer to: STARTUP BATTERY DISCONNECT AND CONNECT .

scientia non olet · About LEMON Manuals