LEMON Manuals: Even more car manuals for everyone
Home >> Jaguar >> 2019 >> XF S >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 13 (Fuel Tank And Lines - Fuel Tank And Lines - Diesel -- XF/(X260)) >> Fuel Tank And Lines - Diesel (G1800234) >> Diagnosis And Testing >> Fuel Tank And Lines - TDV6 3.0L Diesel >> Mis-Fuelling Issues/Accidentally Filling The Fuel Tank With Gasoline Instead Of Diesel >> Mis-fuelling Procedure 2

Mis-fuelling Procedure 2

WARNING: This page is about a different variant/trim than selected.
SYMPTOM POSSIBLE CAUSES ACTION
Mis-fuelling issue. The diesel fuel tank has been filled with gasoline The vehicle has been incorrectly fuelled and the ignition switch has been switched to the ON  position
  1. Referring to the relevant article in the repair information, drain the fuel tank
  2. Remove the fuel pump module and fuel level sensor
  3. Remove all traces of residual fuel within the fuel tank using clean absorbent cloth/paper
  4. Invert the fuel pump module and fuel level sensor to remove all traces of residual fuel
  5. Remove the fuel filter and discard
  6. Disconnect the fuel feed to the highpressure fuel pump
  7. Flush all the fuel lines with clean diesel
  8. Reassemble the fuel pump module and fuel level sensor to the fuel tank
  9. Install a new fuel filter
  10. Fully fill the fuel tank with clean diesel
  11. Road test the vehicle for at least 10 miles/16Km, checking for normal engine operation and no stored DTC'S
  12. Return the vehicle to the customer
scientia non olet · About LEMON Manuals