LEMON Manuals: Even more car manuals for everyone
Home >> Jaguar >> 2019 >> XF S >> Repair and Diagnosis >> External Pages >> Different car >> Section 276 (Rear Disc Brake System -- XE/(760)) >> Rear Disc Brake (G1842107) >> Removal And Installation >> Brake Caliper (G1822055) >> Removal

Brake Caliper (G1822055): Removal

WARNING: This page is about a different car, the 2020 Jaguar XE and 2019 Jaguar XE. However, it is still accessible from the selected car via links, so may be relevant.
WARNING: If the brake pad wear warning light has been activated, a new brake pad wear sensor must be installed.
CAUTION: Brake fluid will damage paint finished surfaces. If spilled, immediately remove the fluid and clean the area with water.
NOTE: Removal steps in this procedure may contain installation details.
  1. Connect the diagnostic tool and set the electronic park brake (EPB) to the maintenance position.
  2. NOTE: This step is only required if the diagnostic tool is not available.

    Refer to: ELECTRIC PARK BRAKE SERVICE MODE ACTIVATION AND DEACTIVATION

  3. NOTE: This step is only required if the vehicle has no battery power.

    Refer to: ELECTRIC PARK BRAKE RELEASE WHEN THE VEHICLE HAS NO ELECTRICAL POWER

  4. WARNING: Make sure to support the vehicle with axle stands.

    Raise and support the vehicle.

  5. Refer to: WHEEL AND TIRE
  6. G11305894Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
  7. CAUTION: The brake pad wear indicator sensor is easily damaged. Do not use a lever to remove the sensor. Use fingers only.
    G11305895Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Inspect the brake pad wear sensor for signs of wear or damage. Install a new sensor if necessary.

  8. CAUTION:
    • Inspect the brake hose sealing washers for signs of damage, if damage is present discard the sealing washers.
    • Be prepared to collect escaping fluids.
    NOTE: Make sure that all openings are sealed.
    G11308658Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Torque  : 32Nm 

  9. CAUTION: Be prepared to collect escaping fluids.
    NOTE: Make sure that all openings are sealed.
    G11308659Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Remove the flexible brake hose.

    Renew Part: Brake hose  Quantity: 1. 

    Torque  : 15Nm 

  10. G11308660Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Torque  : 28Nm 

  11. CAUTION: Remove and discard the O-ring seal.
    NOTE: Do not disassemble further if the component is removed for access only.
    G11308661Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Renew Part: Electric park brake actuator O-ring seal  Quantity: 1. 

    Torque  : 8Nm 

scientia non olet · About LEMON Manuals