LEMON Manuals: Even more car manuals for everyone
Home >> Jaguar >> 2019 >> XF S >> Repair and Diagnosis >> External Pages >> Different car >> Section 151 (Engine Cooling - V6 S/C 3.0L Petrol -- XE/(760)) >> Engine Cooling - V6 S/C 3.0L Petrol (G1824624) >> Removal And Installation >> Cooling Module (G1818106) >> Removal

Cooling Module (G1818106): Removal

WARNING: This page is about a different car, the 2019 Jaguar XE. However, it is still accessible from the selected car via links, so may be relevant.
WARNING: Cooling fans may continue to operate after the engine is turned off. They may also start to operate after the engine is turned off and continue operating for up to 10 minutes.
NOTE:
  • Some variation in the illustrations may occur, but the essential information is always correct.
  • Removal steps in this procedure may contain installation details.
  • Some components shown removed for clarity.
  1. WARNING: Make sure to support the vehicle with axle stands.

    Raise and support the vehicle.

  2. Refer to: STARTUP BATTERY DISCONNECT AND CONNECT
  3. Refer to: AIR CONDITIONING SYSTEM RECOVERY, EVACUATION AND CHARGING
  4. G11307229Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Torque  : 3.5Nm 

  5. G11307230Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
  6. G11307231Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Torque  : 9Nm 

  7. G11307232Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
  8. G11307233Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
  9. Refer to: COOLING SYSTEM DRAINING AND VACUUM FILLING 
  10. Refer to: ENGINE UNDERSHIELD - PROJECT 8
  11. CAUTION: Be prepared to collect escaping coolant.
    G11307234Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
  12. G11307235Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
  13. CAUTION: Be prepared to collect escaping coolant.
    G11307236Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
  14. G11307237Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
  15. CAUTION: Be prepared to collect escaping coolant.
    G11307238Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Torque  : 9Nm 

  16. G11307253Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
  17. G11307254Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
  18. Refer to: FRONT BUMPER
  19. G11307165Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
  20. CAUTION:
    • Immediately cap all refrigerant lines to prevent ingress of dirt and moisture.
    • Before disconnecting any components, make sure the area is clean and free from foreign material. When disconnected all openings must be sealed.
    • A new O-ring seal is to be installed.
    • Take care not to damage the O-ring seals during installation.
    G11307166Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Torque  : 20Nm 

  21. CAUTION:
    • Immediately cap all refrigerant lines to prevent ingress of dirt and moisture.
    • Before disconnecting any components, make sure the area is clean and free from foreign material. When disconnected all openings must be sealed.
    • A new O-ring seal is to be installed.
    • Take care not to damage the O-ring seals during installation.
    G13909223Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Torque  : 20Nm 

  22. NOTE: If equipped.
    G11313044Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Torque 

    M12 Bolts: 90Nm 

    M10 Bolts: 45Nm 

  23. CAUTION: Make sure that the cooling module is supported for this step.
    G11307168Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Torque  : 9Nm 

  24. CAUTION: Make sure that the cooling module is supported for this step.
    G11307169Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC

    Torque  : 9Nm 

  25. G11307170Courtesy of JAGUAR LAND ROVER NORTH AMERICA, LLC
scientia non olet · About LEMON Manuals