LEMON Manuals: Even more car manuals for everyone
Home >> Jaguar >> 2015 >> XFR-S >> Repair and Diagnosis >> External Pages >> Different car >> Section 79 (Engine - V6 S/C 3.0L Petrol -- XF/X250) >> Engine - V6 S/C 3.0L Petrol >> Engine - RWD (G1574188) >> Removal >> Special Tool(S)

Special Tool(S)

WARNING: This page is about a different car, the 2015 Jaguar XF, 2014 Jaguar XF, and 2013 Jaguar XF. However, it is still accessible from the selected car via links, so may be relevant.
G11416336
 303-021 
Engine support bracket
G11416337
 303-1435 
Engine Lifting Brackets Rear
G11416338
 303-1436 
Engine Lifting Bracket Front
NOTE:
  • Some variation in the illustrations may occur, but the essential information is always correct.
  • Some illustrations may show the engine removed for clarity.
  1. Refer to: Battery Disconnect and Connect (Battery, Mounting and Cables, General Procedures).
  2. Refer to: Cooling System Partial Draining, Filling and Bleeding (V6 S/C 3.0L Petrol, General Procedures).
  3. Refer to: Hood (Front End Body Panels, Removal and Installation).
  4. Refer to: Cooling Fan Motor and Shroud (V6 S/C 3.0L Petrol, Removal and Installation).
  5. Refer to: Secondary Bulkhead Left Panel - TDV6 3.0L Diesel/V6 S/C 3.0L Petrol/V8 N/A 5.0L Petrol/V8 S/C 5.0L Petrol (Front End Body Panels, Removal and Installation).
  6. Refer to: Secondary Bulkhead Right Panel - TDV6 3.0L Diesel/V6 S/C 3.0L Petrol/V8 S/C 5.0L Petrol (Front End Body Panels, Removal and Installation).
  7. Refer to: Transmission - V6 S/C 3.0L Petrol/V8 S/C 5.0L Petrol (Automatic Transmission/Transaxle - GTDi 2.0L Petrol/TD4 2.2L Diesel/TDV6 3.0L Diesel/V6 S/C 3.0L Petrol/V8 S/C 5.0L Petrol, RWD, Removal).
  8. G11416339
  9. WARNING: Do not smoke or carry lighted tobacco or open flame of any type when working on or near any fuel related components. Highly flammable vapors are always present and may ignite. Failure to follow these instructions may result in personal injury.
    CAUTION: Be prepared to collect escaping fuel.
    G11416340
  10. Siphon the fluid from the power steering reservoir.
  11. CAUTION: Be prepared to collect escaping fluids.
    G11416341
  12. WARNING: Be prepared to collect escaping fluids.
    NOTE: Discard the sealing washers.
    G11416342
  13. NOTE: Left Hand illustration shown, Right Hand is similar.
    G11416343
  14. CAUTION: Be prepared to collect escaping coolant.
    G11416344
  15. CAUTION: Be prepared to collect escaping coolant.
    G11416345
  16. CAUTION: Be prepared to collect escaping coolant.
    G11416346
  17. CAUTION: Be prepared to collect escaping coolant.
    G11416347
  18. CAUTION: Be prepared to collect escaping coolant.
    G11416348
  19. CAUTION: Be prepared to collect escaping coolant.
    G11416349
  20. G11416350
  21. G11416351
  22. G11416352

    Special Tool(s):  303-1435

    Torque Specification: 25 Nm 

  23. CAUTION: Be prepared to collect escaping coolant.
    G11416353
  24. G11416354
  25. G11416355

    Special Tool(s):  303-1436

    Torque Specification: 25 Nm 

  26. CAUTION: Be prepared to collect escaping coolant.
    G11416356
  27. G11416357
  28. G11416358
  29. CAUTION: The air conditioning (A/C) system will remain fully charged during this procedure, care must be taken when positioning the assembly aside.
    G11416359
  30. G11416360
  31. G11416361
  32. G11416362
  33. G11416363
  34. G11416364
  35. G11416365
  36. G11416366
  37. G11416367

    Remove the special tool.

    Special Tool(s):  303-021

  38. NOTE: This step requires the aid of another technician.
    G11416368

    Using a suitable tool, remove the engine.

    Special Tool(s):  303-1435, 303-1436

scientia non olet · About LEMON Manuals