Brake Shoes &/Or Pads: Remove & Replace
WARNING: This page is about the Trooper LS, 4WD, which is a different variant/trim than selected.
Includes: Clean, lube and/or replace Brake Hardware as necessary. Adjust Brakes (where applicable).
Includes: Repack Wheel Bearings (where applicable).
DOES NOT include refinishing.| Applies To | Note | Standard Hours | Warranty Hours | Skill Level |
|---|---|---|---|---|
| All,w/Rear Disc Brakes,Both Axles | 1.8 | B | ||
| All,w/Rear Drum Brakes,Both Axles | 2.2 | B | ||
| Front,Both Sides | 1.0 | B | ||
| Rear,w/Disc Brakes,Both Sides | 1.0 | B | ||
| Rear,w/Drum Brakes,Both Sides | 1.4 | B | ||
| Combination Procedure: AXLE OR WHEEL SEAL: Replace: | ||||
| Both,Rear | 0.8 | B | ||
| One Side,Rear | 0.6 | B | ||
| Combination Procedure: BRAKE HOSE: Replace: | ||||
| Each Additional | 0.2 | B | ||
| One,w/ABS | 0.5 | B | ||
| One,w/o ABS | 0.3 | B | ||
| Combination Procedure: CALIPER: Overhaul: | ||||
| w/ABS,One | Includes: Bleed Brakes. | 0.7 | B | |
| w/o ABS,One | Includes: Bleed Brakes. | 0.5 | B | |
| Combination Procedure: CALIPER: Replace: | ||||
| w/ABS,One | Includes: Bleed Brakes. | 0.5 | B | |
| w/o ABS,One | Includes: Bleed Brakes. | 0.3 | B | |
| Combination Procedure: DISC ROTOR: Remove and Install for Refinishing: NOTE: This operation does not apply to drive axles. If on vehicle refinishing is not possible use appropriate repair operation. | ||||
| 4WD, Each | 0.7 | B | ||
| Combination Procedure: DISC ROTOR: Replace: | ||||
| 4WD, Each | 0.7 | B | ||
| Each | 0.7 | B | ||
| Combination Procedure: PARKING BRAKE SHOE & LINING: Replace: | ||||
| Both Sides | 0.6 | B | ||
| Combination Procedure: WHEEL BEARING: Repack: | ||||
| 4WD, Front,Both Sides | 1.4 | B | ||
| Combination Procedure: WHEEL BEARING: Replace: | ||||
| 4WD, One Side,Front | 0.8 | B | ||
| Combination Procedure: WHEEL CYLINDER: Overhaul: | ||||
| w/ABS,One,Off Vehicle | Includes: Bleed Brakes. | 0.7 | B | |
| w/ABS,One,On Vehicle | Includes: Bleed Brakes. | 0.5 | B | |
| w/o ABS,One,Off Vehicle | Includes: Bleed Brakes. | 0.5 | B | |
| w/o ABS,One,On Vehicle | Includes: Bleed Brakes. | 0.3 | B | |
| Combination Procedure: WHEEL CYLINDER: Replace: | ||||
| w/ABS,One | Includes: Bleed Brakes. | 0.5 | B | |
| w/o ABS,One | Includes: Bleed Brakes. | 0.3 | B | |