LEMON Manuals: Even more car manuals for everyone
Home >> Hyundai >> 2015 >> Sonata Eco >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 67 (Fuel Delivery System (HEV)) >> Fuel Tank >> Repair procedures >> Removal

Repair procedures: Removal

WARNING: This page is about a different variant/trim than selected.
  1. Release the residual pressure in fuel line (Refer to "RELEASE RESIDUAL PRESSURE IN FUEL LINE ").
  2. Lift the vehicle.
  3. Disconnect the fuel pump & the fuel tank pressure sensor extension connector (A).
    Fig 1: Identifying Fuel Pump & Fuel Tank Pressure Sensor Extension Connector
    G10588688Courtesy of HYUNDAI MOTOR AMERICA
  4. Disconnect the fuel feed tube quick connector (B).
    Fig 2: Disconnecting Fuel Feed Tube Quick Connector
    G10588689Courtesy of HYUNDAI MOTOR AMERICA
  5. Remove the undercover (A).
    Fig 3: Removing Undercover
    G10588690Courtesy of HYUNDAI MOTOR AMERICA
  6. Remove the center muffler assembly (Refer to "ENGINE INTAKE & EXHAUST SYSTEM - SONATA HEV article).
  7. Support the fuel tank with a jack.
  8. Disconnect the fuel filler hose (A).
    Fig 4: Disconnecting Fuel Filler Hose
    G10588691Courtesy of HYUNDAI MOTOR AMERICA
  9. Disconnect the vapor hose quick-connector (A).
    Fig 5: Disconnecting Vapor Hose Quick-Connector
    G10588692Courtesy of HYUNDAI MOTOR AMERICA
  10. Remove the brake line bracket (A).
    Fig 6: Removing Brake Line Bracket
    G10588693Courtesy of HYUNDAI MOTOR AMERICA
  11. Remove the fuel tank from the vehicle after removing the fuel tank band (A).
    Fig 7: Removing Fuel Tank Band
    G10588694Courtesy of HYUNDAI MOTOR AMERICA
    NOTE: Remove the fuel tank band as shown in illustration below.
    Fig 8: Identifying Fuel Tank Band
    G10588695Courtesy of HYUNDAI MOTOR AMERICA
scientia non olet · About LEMON Manuals