Auxiliary Temperature Valve Actuator Replacement (Delphi)

WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2008 GMC Yukon XL, 2008 GMC Yukon, 2008 Chevrolet Tahoe, 2008 Chevrolet Suburban, and 2008 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.

Fig 1: Auxiliary Temperature Valve Actuator (Delphi)

Courtesy of GENERAL MOTORS CORP.

Callout	Component Name
NOTE: In order to avoid actuator damage, DO NOT apply power to the actuator when it is not installed in the HVAC module. Preliminary Procedure Remove the right rear quarter trim panel. Refer to Rear Quarter Trim Panel Replacement - Right Side (Standard Wheelbase) or Rear Quarter Trim Panel Replacement - Right Side (Extended Wheelbase) . Disconnect the electrical connector from the temp door actuator (2).
1	Temp Door Actuator Screws (Qty: 2) NOTE: Refer to Fastener Notice . Tighten: 2.5 N.m (16 lb in)
2	Temp Door Actuator Procedure: Re-calibrate the air temp actuator. Refer to Actuator Recalibration .

Callout

Component Name

NOTE: In order to avoid actuator damage, DO NOT apply power to the actuator when it is not installed in the HVAC module.

Preliminary Procedure

Remove the right rear quarter trim panel. Refer to Rear Quarter Trim Panel Replacement - Right Side (Standard Wheelbase) or Rear Quarter Trim Panel Replacement - Right Side (Extended Wheelbase) .
Disconnect the electrical connector from the temp door actuator (2).

Temp Door Actuator Screws (Qty: 2)

NOTE: Refer to Fastener Notice .

Tighten: 2.5 N.m (16 lb in)

Temp Door Actuator
Procedure:
Re-calibrate the air temp actuator. Refer to Actuator Recalibration .