Rattle In Sunroof Area At Highway Speeds (03-08-67-003)
Publication date: 2003-04-28Reference number: 03-08-67-003
RATTLE IN SUNROOF AREA AT HIGHWAY SPEEDS
TECHNICAL SERVICE BULLETIN
Reference Number(s): 03-08-67-003, Date of Issue:
April 28, 2003
| HUMMER: | 2003 H2 |
| SECTION: | 08 - Body and Accessories |
CONDITION
Some customers may comment on a rattle in the sunroof area at highway speeds.
CAUSE
The wind deflector screws may be coming loose.
CORRECTION
Tighten the wind deflector screws using the following procedure.
- Inspect the seal between the roof and the deflector. Make sure that the seal is properly in its groove along the entire front edge of the deflector for proper sealing to the roof.
- Inspect the alignment of the sunroof wind deflector to the opening.
- Remove one nut at a time and apply a small amount of GM Threadlocker Medium Strength-Blue, P/N 12345382 (in Canada, P/N 10953489), to the nut.
- Carefully tighten the screws to achieve a good seal between the roof and the deflector.
WARRANTY INFORMATION
For vehicles repaired under warranty, use:
WARRANTY INFORMATION
| Labor Op. | Description | Labor Time |
|---|---|---|
| B2230 | Air Deflector-Roof Opening - Replace | 0.2 hr |