DTC P059F, P05A3, P05A8, P05C0 (1.5 L Engine)

DTC P059F  : Shutter Grille Assembly (Upper) Malfunction DTC P05A3  : Shutter Grille Actuator (Upper) Malfunction DTC P05A8  : Shutter Grille Actuator (Upper) Malfunction DTC P05C0  : Shutter Grille Actuator (Upper) Temperature Malfunction

NOTE:  Before you troubleshoot, review the general troubleshooting information .

DTC (PGM-FI)

1. Problem verification

   -1. Turn the vehicle to the ON mode.

   -2. Clear the DTC with the HDS.

   -3. Turn the vehicle to the OFF (LOCK) mode.

   -4. Start the engine, then let it idle.

   -5. Check for Pending or Confirmed DTCs with the HDS.

   DTC Description	Confirmed DTC	Pending DTC
   P059F Shutter Grille Assembly (Upper) Malfunction
   P05A3 Shutter Grille Actuator (Upper) Malfunction
   P05A8 Shutter Grille Actuator (Upper) Malfunction
   P05C0 Shutter Grille Actuator (Upper) Temperature Malfunction

   Is DTC P059F, P05A3, P05A8, or P05C0 is indicated?

   YES 

   Go to step 2.

   NO 

   Intermittent failure, the system is OK at this time. Check for poor connections or loose terminals at the shutter grille (upper) and the PCM. If the on-board snapshot of this DTC is recorded, try to reproduce the failure under the same conditions with the on-board snapshot .

2. Shutter grille condition check

   -1. Turn the vehicle to the OFF (LOCK) mode.

   -2. Check for condition (damage, fixation, foreign material, etc.) at shutter grille.

   Is the shutter grille OK?

   YES (Without wireless charger)

   Go to step 3.

   YES (With wireless charger)

   Go to step 4.

   NO 

   Reassembly or repair the shutter grille, if needed.

3. Shorted wire check (VMP line)

   -1. Check the following fuse.

   Fuse

   No. A23

   Is the fuse OK?

   YES 

   Go to step 6.

   NO 

   Repair a short in the VMP wire between shutter grille (upper) and the No. A23 fuse. Also replace the No. A23 fuse.

4. Shorted wire check (VMP line)

   -1. Check the following fuse.

   Fuse

   No. G31

   Is the fuse OK?

   YES 

   Go to step 5.

   NO 

   Repair a short in the VMP wire between shutter grille (upper) and the No. G31 fuse. Also replace the No. G31 fuse.

5. Shorted wire check (+B FI ECU MAIN line)

   -1. Check the following fuse.

   Fuse

   No. A23

   Is the fuse OK?

   YES 

   Go to step 6.

   NO 

   Repair a short in the +B FI ECU MAIN wire between the A23 fuse and the No. G31 fuse. Also replace the No. A23 fuse.

6. Open wire check (VMP line)

   -1. Disconnect the following connector.

   Shutter grille (upper) 4P connector

   -2. Measure the voltage between test points 1 and 2.

   Test condition	Vehicle OFF (LOCK) mode
   	Shutter grille (upper) 4P connector: disconnected
   Test point 1	Shutter grille (upper) 4P connector (female terminals) No. 1:
   Test point 2	Body ground

   Courtesy of HONDA, U.S.A., INC.

   Is there battery voltage?

   YES 

   Go to step 7.

   NO 

   Repair an open in the VMP wire between the shutter grille (upper) and the No. A23 fuse (with wireless charger: No. G31 fuse ).

7. Open wire check (GND line)

   -1. Measure the resistance between test points 1 and 2.

   Test condition	Vehicle OFF (LOCK) mode
   	Shutter grille (upper) 4P connector: disconnected
   Test point 1	Shutter grille (upper) 4P connector (female terminals) No. 4:
   Test point 2	Body ground

   Courtesy of HONDA, U.S.A., INC.

   Is there 1.0 Ω or less?

   YES 

   Replace the shutter grille (upper) .

   NO 

   Repair an open in the GND wire between the shutter grille (upper) and G351.