LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2023 >> Hummer EV Edition 1 >> Repair and Diagnosis >> Accessories & Equipment >> Gauges & Instrument Panels >> Instrument Panel Trim And Console Trim >> Repair Instructions >> Instrument Panel Trim Pad Replacement - Right Side >> Installation Procedure

Installation Procedure

  1. GM5791775Courtesy of GENERAL MOTORS COMPANY

    On/Off Vehicle Switch (1) - Install

  2. Secure the retaining tabs.
  3. GM5788655Courtesy of GENERAL MOTORS COMPANY

    Communication Interface Module Microphone (1) - Install

  4. Secure the retaining tabs.
  5. GM5787158Courtesy of GENERAL MOTORS COMPANY

    Mobile Telephone Microphone (1) - Install

  6. Secure the retaining tabs.
  7. GM5811495Courtesy of GENERAL MOTORS COMPANY

    Connect the electrical connectors.

  8. Instrument Panel Trim Pad - Right Side (1) - Install
  9. GM5811494Courtesy of GENERAL MOTORS COMPANY
    CAUTION:

    Refer to Fastener Caution .

    Instrument Panel Trim Pad Bolt (1) - Install and tighten [8x] - Fastener Specifications 

  10. GM5812560Courtesy of GENERAL MOTORS COMPANY

    Instrument Panel Trim Plate (2) - Install

  11. Instrument Panel Trim Plate Bolt (1) - Install and tighten [2x] - Fastener Specifications 
  12. GM5810877Courtesy of GENERAL MOTORS COMPANY

    Instrument Panel Air Outlet Bezel (1) - Install

  13. GM5810876Courtesy of GENERAL MOTORS COMPANY

    Instrument Panel Outer Air Outlet Bolt (1) - Install and tighten [4x] - Fastener Specifications 

  14. GM5765249Courtesy of GENERAL MOTORS COMPANY
    NOTE:

    Left side shown, right side similar.

    Radio Front Speaker Grille- Right Side (2) - Install

  15. Secure the retaining tabs.
  16. Radio Front Speaker Grille Bolt (1) - Install and tighten - Fastener Specifications
  17. GM5764763Courtesy of GENERAL MOTORS COMPANY

    Connect the electrical connectors.

  18. Radio Control (1) - Install
  19. GM5764761Courtesy of GENERAL MOTORS COMPANY

    Radio Control Bolt (1) - Install and tighten [2x] - Fastener Specifications

  20. GM5764757Courtesy of GENERAL MOTORS COMPANY

    Radio Control Bolt (1) - Install and tighten [2x] - Fastener Specifications

  21. GM5764596Courtesy of GENERAL MOTORS COMPANY

    Instrument Panel Upper Trim Panel Cover (1) - Install

  22. Secure the retaining tabs.
  23. GM5764598Courtesy of GENERAL MOTORS COMPANY

    Instrument Panel Bolt Cover (1) - Install [2x]

  24. Secure the retaining tab.
  25. GM5807912Courtesy of GENERAL MOTORS COMPANY

    Instrument Panel Lower Trim Panel (2) - Install

  26. Instrument Panel Lower Trim Panel Bolt (1) - Install and tighten [6x] - Fastener Specifications 
  27. GM5796821Courtesy of GENERAL MOTORS COMPANY

    Connect the electrical connectors.

  28. Instrument Panel Knee Bolster (1) - Install
  29. GM5796820Courtesy of GENERAL MOTORS COMPANY

    Instrument Panel Knee Bolster Bolt (2) - Install and tighten [2x] - Fastener Specifications 

  30. Instrument Panel Fuse Block Access Hole Cover (1) - Install
  31. GM5807065Courtesy of GENERAL MOTORS COMPANY

    Instrument Panel Compartment (1) - Install

  32. GM5807064Courtesy of GENERAL MOTORS COMPANY

    Open the instrument panel compartment door.

  33. Instrument Panel Compartment Bolt (1) - Install and tighten [3x] - Fastener Specifications 
  34. GM5807063Courtesy of GENERAL MOTORS COMPANY

    Instrument Panel Compartment Bolt (1) - Install and tighten [5x] - Fastener Specifications 

  35. GM5787899Courtesy of GENERAL MOTORS COMPANY

    Front Floor Console (1) - Install

  36. Connect the electrical connectors to the front floor console (1).
  37. GM5776105Courtesy of GENERAL MOTORS COMPANY

    Front Floor Console Retainer Bolt (2) - Install and tighten [5x] - Fastener Specifications 

  38. Front Floor Console Bolt Access Hole Cover (1) - Install
  39. GM5777829Courtesy of GENERAL MOTORS COMPANY

    Front Floor Console Lower Applique (1) - Install

  40. GM5776102Courtesy of GENERAL MOTORS COMPANY

    Front Floor Console Extension Panel (1) - Install

  41. GM5776104Courtesy of GENERAL MOTORS COMPANY

    Front Floor Console Retainer Bolt (2) - Install and tighten [5x] - Fastener Specifications 

  42. Front Floor Console Bolt Access Hole Cover (1) - Install
  43. GM6039681Courtesy of GENERAL MOTORS COMPANY

    Rear Floor Mat (1) - Install

  44. GM6029241Courtesy of GENERAL MOTORS COMPANY

    Tire Air Compressor (2) - Install

  45. Tire Repair Sealer and Tire Air Compressor Retainer (1) - Install and hand tighten
  46. GM5776103Courtesy of GENERAL MOTORS COMPANY

    Front Floor Console Lower Applique (1) - Install

  47. GM5776101Courtesy of GENERAL MOTORS COMPANY

    Front Floor Console Extension Panel (1) - Install

  48. GM5776100Courtesy of GENERAL MOTORS COMPANY

    Front Floor Console Extension Bolt (2) - Install and tighten - Fastener Specifications 

  49. Front Floor Console Extension Panel Bolt Access Hole Cover (1) - Install
  50. GM5776099Courtesy of GENERAL MOTORS COMPANY

    Install the left and right front floor mat (1).

  51. Return the seat to its original position.
  52. GM5811463Courtesy of GENERAL MOTORS COMPANY

    Connect the electrical connector.

  53. Instrument Cluster (1) - Install
  54. GM5811461Courtesy of GENERAL MOTORS COMPANY

    Instrument Cluster Bolt (1) - Install and tighten [4x] - Fastener Specifications

  55. GM5775850Courtesy of GENERAL MOTORS COMPANY

    Connect the electrical connector.

  56. Instrument Panel Extension (1) - Install
  57. GM5775880Courtesy of GENERAL MOTORS COMPANY
    NOTE:

    Left side shown, right side similar.

    Connect the electrical connector.

  58. Windshield Garnish Molding- Left Side and Right Side (1) - Install [2x]
  59. GM5775868Courtesy of GENERAL MOTORS COMPANY
    NOTE:

    Left side shown, right side similar.

    Windshield Pillar Assist Handle Bolt- Left Side and Right Side (2) - Install and tighten [4x] - Fastener Specifications

  60. Windshield Pillar Assist Handle Cover- Left Side and Right Side (1) - Install [4x]
  61. GM5775858Courtesy of GENERAL MOTORS COMPANY
    NOTE:

    Left side shown, right side similar.

    Body Hinge Pillar Garnish Molding- Left Side and Right Side (1) - Install [2x]

  62. Install the weatherstrip as necessary.
  63. GM5775549Courtesy of GENERAL MOTORS COMPANY
    NOTE:

    Left side shown, right side similar.

    Instrument Panel Outer Trim Cover- Left Side and Right Side (1) - Install [2x]

scientia non olet · About LEMON Manuals