LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2020 >> Terrain Denali, FWD >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 4 (Engine Mechanical - 1.5L (LYX)) >> Repair Instructions >> Engine Replacement (Front Wheel Drive) >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
  1. Relieve the fuel system pressure. Fuel Pressure Relief
  2. GM4592887Courtesy of GENERAL MOTORS COMPANY

    Fuel Feed Front Pipe (1) @ Engine - Disconnect - Fuel Feed Front Pipe Replacement

  3. Recover the refrigerant. Refrigerant Recovery and Recharging (R-134a)Refrigerant Recovery and Recharging (R-1234yf)
  4. GM4583622Courtesy of GENERAL MOTORS COMPANY

    Intake Manifold Cover(3) - Remove - Intake Manifold Cover Replacement 

  5. Charge Air Cooler Inlet Air Tube - Remove - Charge Air Cooler Inlet Air Tube Replacement
  6. Charge Air Cooler Outlet Air Tube - Remove - Charge Air Cooler Outlet Air Tube Replacement
  7. Air Cleaner Assembly - Remove - Air Cleaner Assembly Replacement
  8. GM4582789Courtesy of GENERAL MOTORS COMPANY

    Battery Tray(3) - Remove - Battery Tray Replacement

  9. Radiator Inlet Hose - Remove - Radiator Inlet Hose Replacement (LYX)Radiator Inlet Hose Replacement (LTG with KL9)
  10. Radiator Outlet Hose - Remove - Radiator Outlet Hose Replacement (LYX)Radiator Outlet Hose Replacement (LTG with KL9)
  11. GM4599595Courtesy of GENERAL MOTORS COMPANY

    Power Brake Booster Vacuum Pipe(1) - Remove - Power Brake Booster Vacuum Pipe Replacement (LYX)Power Brake Booster Vacuum Pipe Replacement (LTG)

  12. Heater Inlet Hose - Remove - Heater Inlet Hose Replacement (LYX AWD without KL9)Heater Inlet Hose Replacement (LYX with KL9)Heater Inlet Hose Replacement (LTG with KL9)
  13. Heater Outlet Hose - Remove - Heater Outlet Hose Replacement (LYX without KL9)
  14. GM4138084Courtesy of GENERAL MOTORS COMPANY

    Range Selector Lever Cable(1)@Transmission - Disconnect - Range Selector Lever Cable Replacement

  15. Underbody Front Air Deflector - Remove - Underbody Front Air Deflector Replacement (Equinox)Underbody Front Air Deflector Replacement (Terrain)
  16. Exhaust Front Pipe - Remove - Exhaust Front Pipe Replacement (LTG)Exhaust Front Pipe Replacement (LYX)
  17. Air Conditioning Evaporator Connector Hose/Tube and Compressor Hose@Air Conditioning Compressor - Disconnect - Air Conditioning Evaporator Connector Hose/Tube and Compressor Hose Replacement (LYX)Air Conditioning Evaporator Connector Hose/Tube and Compressor Hose Replacement (LTG)
  18. GM4583249Courtesy of GENERAL MOTORS COMPANY

    Transmission Fluid Cooler Inlet and Outlet Pipe(2)@Radiator Assembly - Disconnect - Transmission Fluid Cooler Inlet and Outlet Pipe Replacement (LTG/LYX)

  19. Disconnect electrical connections and reposition harnesses as needed.
  20. Front Wheel Drive Half Shaft-Left Side(1) - Remove - Front Wheel Drive Half Shaft Replacement - Left Side
  21. Front Wheel Drive Half Shaft-Right Side(1) - Remove - Front Wheel Drive Half Shaft Replacement - Right Side (AWD)Front Wheel Drive Half Shaft Replacement - Right Side (M3U, MHG, MNH, MNK with FWD)Front Wheel Drive Half Shaft Replacement - Right Side (M3D, M3H with FWD)
  22. GM4582608Courtesy of GENERAL MOTORS COMPANY

    Intermediate Steering Shaft(1) - Remove - Intermediate Steering Shaft Replacement (Equinox)Intermediate Steering Shaft Replacement (Terrain)

  23. GM3992231Courtesy of GENERAL MOTORS COMPANY
    NOTE:

    Right side shown, left side is similar.

    Remove left and right side the stabilizer link nuts (1) then disconnect the links at the stabilizer. Stabilizer Shaft Link Replacement (Equinox)Stabilizer Shaft Link Replacement (Terrain)

  24. GM3992236Courtesy of GENERAL MOTORS COMPANY
    NOTE:

    Right side shown, left side is similar.

    Remove the left and right side tie rod nuts (1), then disconnect the tie rods (2) from the steering knuckles. Steering Linkage Outer Tie Rod Replacement

  25. GM4592875Courtesy of GENERAL MOTORS COMPANY

    Evaporative Emission Front Hose(1) - Remove - Evaporative Emission Front Hose Replacement

  26. Position a suitable engine table or equivalent under the cradle to support the cradle and powertrain.
  27. GM4597434Courtesy of GENERAL MOTORS COMPANY

    Engine Mount Fastener(1) - Remove and DISCARD [2x] - Engine Mount Replacement 

  28. GM4572700Courtesy of GENERAL MOTORS COMPANY
    NOTE:

    ONLY the fasteners (2) should be removed and DISCARDED

    Transmission Mount Fastener(2) - Remove and DISCARD[3x] - Transmission Mount Replacement - Left Side

  29. GM4589451Courtesy of GENERAL MOTORS COMPANY
    NOTE:

    Use a suitable device to hold the cradle while removing the fasteners.

    NOTE:

    Remove ONLY the body to frame bolts as the powertrain will be removed while still bolted to the frame.

    Remove bolts necessary to remove the cradle (1) (2) and (3). Drivetrain and Front Suspension Cradle Replacement (Front Wheel Drive)Drivetrain and Front Suspension Cradle Replacement (All Wheel Drive)

  30. Carefully lower the engine table and raise the body on the hoist until the engine/transaxle and frame are separated from the vehicle.
  31. Separate the engine from the transmission. Transmission Replacement (FWD)Transmission Replacement (AWD)
  32. Install the engine to a suitable engine stand.
  33. Transfer components as necessary.
scientia non olet · About LEMON Manuals