Fastener Specifications
WARNING: This page is about a different car, the 2017 Cadillac ATS. However, it is still accessible from the selected car via links, so may be relevant.
Single Use Non-Threaded Fasteners/Components
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|---|
| Application |
| Camshaft Position Actuator Solenoid Valve O-ring |
| Charge Air Cooler Inlet Pipe Seal |
| Crankshaft Position Sensor Seal Ring |
| Engine Coolant Temperature Sensor Seal |
| Fuel Pump Gasket |
| Fuel Pump O-Ring |
| Fuel Sender Assembly Seal |
| Fuel Tank Module Seal |
| High Pressure Fuel Pump Gasket |
| High Pressure Fuel Pump O-ring |
| Throttle Body Gasket |
| Turbocharger Air Inlet Adapter Seal |
| Valve Rocker Arm Oil Control Valve O-ring |
Single Use Threaded Fastener/Component Tightening Specifications
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Fuel Feed Intermediate Pipe Fitting | 28 N.m (21 lb ft) |
| Fuel Feed Pipe | 28 N.m (21 lb ft) |
| Fuel Injection Fuel Rail Fuel Pressure Sensor | 33 N.m (24 lb ft) |
| Fuel Pump Bolt - LF4 | |
|
15 N.m (11 lb ft) |
|
60 degrees |
| Fuel Pump Bolt - LGX | 25 N.m (18 lb ft) |
Reusable Threaded Fastener Tightening Specifications
|
NOTE:
All fasteners listed in this table can be reused after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Accelerator Pedal Position Sensor Fastener | 9 N.m (80 lbin) |
| Air Cleaner Outlet Duct Clamp | 4 N.m (35 lb in) |
| Air Cleaner Upper Housing Bolt | 2.3 N.m (20 lb in) |
| Camshaft Position Actuator Locating Pin Control Valve Bolt | 10 N.m (89 lb in |
| Camshaft Position Actuator Solenoid Valve Bolt | 10 N.m (89 lb in |
| Camshaft Position Sensor Bolt | 10 N.m (89 lb in |
| Charge Air Bypass Valve Hose Clamp | 3.5 N.m (31 lb in |
| Charge Air Cooler Inlet Pipe Bolt | 9 N.m (80 lb in |
| Chassis Control Module Fastener | 7 N.m (62 lb in) |
| Crankshaft Position Sensor Bolt | 10 N.m (89 lb in) |
| Crankshaft Position Sensor Shield Bolt | 9 N.m (80 lb in) |
| Engine Control Module Bracket Bolt | 4.5 (40 lb in) |
| Engine Control Module Bracket Nut | 4.5 (40 lb in) |
| Engine Coolant Temperature Sensor | 9 N.m (80 lb in) |
| Evaporative Emission Canister Purge Solenoid Valve Fastener | 10 N.m (89 lb in) |
| Fuel Feed Pipe Bolt-LF4 | 50 N.m (37 lb ft) |
| Fuel Feed Pipe Bolt-LGX | 10 N.m (89 lb in) |
| Fuel Injection Fuel Rail Fastener -LGX | 25 N.m (18 lb ft) |
| Fuel Pump Power Control Module Fastener | 9 N.m (80 lb in) |
| Fuel Rail Fastener-LF4 | |
| First Pass: | 12 N.m (106 lb in) |
| Final Pass: | 25 N.m (18 lb ft) |
| Fuel Tank Filler Pipe Bolt | 2.5N.m (22 lb in) |
| Fuel Tank Filler Pipe Ground Bolt | 9 N.m (80 lb in) |
| Fuel Tank Strap Bolt | 20 N.m (15 lb ft) |
| Heated Oxygen Sensor | 42 N.m (31 lb ft) |
| Ignition Coil Bolt | 10 N.m (89 lb in) |
| Intake Air Pressure and Temperature Sensor Fastener | 10 N.m (89 lb in) |
| Knock Sensor Bolt | 25 N.m (18 lb ft) |
| Manifold Absolute Pressure Sensor Fastener | 10 N.m (89 lb in) |
| Mass Airflow Sensor Bolt | 2.5 N.m (22 lb in) |
| Oil Pump Flow Control Solenoid Valve Bolt | 5 N.m (44 lb in) |
| Positive Crankcase Ventilation Tube Clamp | 4 N.m (35 lb in) |
| Spark Plug | 18N.m (13 lb ft)) |
| Throttle Body Assembly Fastener | 10 N.m (89 lb in) |
| Turbocharger Air Inlet Adapter Fastener | 10 N.m (89 lb in) |
| Turbocharger Inlet Absolute Pressure Sensor Bolt | 5 N.m (44 lb in) |
| Turbocharger Wastegate Actuator Fastener | 20 N.m (15 lb ft) |
| Vacuum Pump Bolt | 10 N.m (89 lb in) |
| Valve Rocker Arm Oil Control Valve Bolt | 10 N.m (89 lb in) |