Fastener Specifications (On Vehicle)
WARNING: This page is about a different variant/trim than selected.
Single Use Non-Threaded Fasteners/Components
|
NOTE:
All fasteners/components listed in this table MUST BE DISCARDED and replaced with NEW after removal. |
|---|
| Application |
| Front Wheel Drive Shaft Seal - Left |
| Front Wheel Drive Shaft Seal - Right |
Reusable Threaded Fastener Tightening Specifications
|
NOTE:
All fasteners listed in this table can be reused after removal. |
|
|---|---|
| Application | Specification |
| Metric (English) | |
| Control Valve Body Bolts | 12 N.m (106 lb in) |
| Control Valve Body Cover Bolts | 12 N.m (106 lb in) |
| Control Valve Body Cover Studs | 12 N.m (106 lb in) |
| Drain Plug | 12 N.m (106 lb in) |
| Fluid Cooler Fitting at Radiator | 38 N.m (28 lb ft) |
| Fluid Cooler Outlet Pipe Retainer Nut | 22 N.m (17 lb ft) |
| Fluid Cooler Pipe Nut | 22 N.m (17 lb ft) |
| Fluid Pressure Test Hole Plug | 12 N.m (106 lb in) |
| Input Speed Sensor Fastener | 9 N.m (80 lb in) |
| Output Speed Sensor Fastener | 12 N.m (106 lb in) |
| Shift Control Knob Retaining Screw | 1.5 N.m (13 lb in) |
| Torque Converter to Flywheel Bolt | 62 N.m (46 lb ft) |
| Transaxle Bracket Bolts | 50 N.m (37 lb ft) |
| Transaxle Front Mount to Transmission Bolts | 57 N.m (42 lb ft) |
| Transaxle Front Mount Through Bolt | 100 N.m (74 lb ft) |
| Transaxle Left Mount to Frame Rail Bolts | 27 N.m (20 lb ft) |
| Transaxle Left Mount Bracket to Transmission Bolts | 57 N.m (42 lb ft) |
| Transaxle Range Selector Cable Bracket Bolt | 25 N.m (18 lb ft) |
| Transaxle Range Switch Lever Nut | 20 N.m (15 lb ft) |
| Transaxle Rear Mount to Frame Bolts | 57 N.m (42 lb ft) |
| Transaxle Rear Mount Through Bolt | 100 N.m (74 lb ft) |
| Transaxle Rear Mount Bracket to Transmission Bolt | 100 N.m (74 lb ft) |
| Transaxle Rear Mount Bracket to PTU | 57 N.m (42 lb ft) |
| Transaxle Shift Control Nut | 25 N.m (18 lb ft) |
| Transaxle to Engine Bolt | 75 N.m (55 lb ft) |
| Transmission Fluid Cooler Pipe Quick Connect Fitting | 38 N.m (28 lb ft) |
| Transmission Fluid Cooler Pipe Mounting Nuts | 22 N.m (16 lb ft) |