Fastener Tightening Specifications
WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2003 GMC Savana Special, 2003 GMC Savana Camper Special, 2003 GMC Savana, 2003 Chevrolet RV Cutaway, and 2003 Chevrolet Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
FASTENER TIGHTENING SPECIFICATIONS
| Application | Specification | |
|---|---|---|
| Metric | English | |
| Accumulator Housing to Valve Body | 11 N.m | 97 lb in |
| Case Center Support | 43 N.m | 32 lb ft |
| Control Valve Assembly to Case | 11 N.m | 97 lb in |
| Cooler Pipe Connector Nut at Case and Radiator | 38 N.m | 28 lb ft |
| Engine Rear Mount to Transmission Bolt | 44 N.m | 32 lb ft |
| Engine Rear Support Bracket to Frame Nut | 44 N.m | 32 lb ft |
| Extension Housing to Case | 34 N.m | 25 lb ft |
| Flywheel Housing Cover to Transmission | 7 N.m | 62 lb in |
| Flywheel to Converter | 43 N.m | 32 lb ft |
| Fourth Clutch Housing | 23 N.m | 17 lb ft |
| Heat Shield to Transmission Bolts | 17 N.m | 13 lb ft |
| Manual Shaft to Detent Lever Nut | 24 N.m | 18 lb ft |
| Oil Pan Drain Plug | 34 N.m | 25 lb ft |
| Oil Pan to Case | 24 N.m | 18 lb ft |
| Oil Test Hole Plug | 11 N.m | 97 lb in |
| Parking Pawl Bracket to Case | 24 N.m | 18 lb ft |
| Pressure Control Solenoid Bracket to Valve Body | 8 N.m | 71 lb in |
| Pump Assembly to Case | 24 N.m | 18 lb ft |
| Pump Body to Cover | 24 N.m | 18 lb ft |
| Rear Servo Cover to Case | 24 N.m | 18 lb ft |
| Solenoid to Valve Body | 8 N.m | 71 lb in |
| Speed Sensor and Bracket Assembly to Case | 11 N.m | 97 lb in |
| Transmission Case to Engine | 44 N.m | 32 lb ft |
| Transmission Mount to Transmission Bolts | 50 N.m | 37 lb ft |
| Valve Body to Case/Lube Pipe | 11 N.m | 97 lb in |
| Valve Body to Case/TFP | 11 N.m | 97 lb in |