Fluorescent Leak Detector

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2003 GMC Savana Special, 2003 GMC Savana Camper Special, 2003 GMC Savana, 2003 Chevrolet RV Cutaway, and 2003 Chevrolet Cutaway. However, it is still accessible from the selected car via links, so may be relevant.

Fluorescent dye will assist in locating any leaks in the A/C system.

Important : PAG oil is water soluble.

Condensation on the evaporator core or the refrigerant lines may wash the PAG oil and fluorescent dye away from the actual leak. Condensation may also carry dye through the HVAC module drain.
Leaks in the A/C system will be indicated in a light green or yellow color when using the leak detection lamp.
Use the leak detection lamp in the following areas:
1. All fittings or connections that use seal washers or O-rings
2. All of the A/C components
3. The A/C compressor shaft seal
4. The A/C hoses and pressure switches
5. The HVAC module drain tube, if the evaporator core is suspected of leaking
6. The service port sealing caps
The sealing cap is the primary seal for the service ports.
Follow the instructions supplied with the J-42220 .
To prevent false diagnosis in the future, thoroughly clean the residual dye from any area where leaks were found. Use a rag and the approved fluorescent dye cleaner J-43872 .