Disassembled Views

WARNING: This page is about a different car, the 2010 GMC Sierra and 2010 Chevrolet Silverado. However, it is still accessible from the selected car via links, so may be relevant.

Fig 1: Intake Manifold/Upper Engine

Courtesy of GENERAL MOTORS CORP.

Callout	Component Name
1	Bolt
2	Nut
3	Throttle Body
4	Throttle Body Seal
5	Manifold Absolute Pressure (MAP) Sensor O-ring Seal
6	MAP Sensor
7	Sequential Multi-Port Fuel Injector Assembly with Fuel Rail
8	Bolt
9	Fuel Injection Fuel Rail Bracket
10	Evaporative (EVAP) Emission Canister Purge Tube
11	EVAP Emission Canister Purge Solenoid Valve
12	EVAP Emission Canister Purge Tube
13	Bolt
14	Fuel Injection Fuel Rail Stop
15	Bolt
16	Intake Manifold
17	Intake Manifold Seal
18	Intake Manifold Gasket
19	Engine Coolant Air Bleed Plug
20	Engine Oil Pressure Sensor
21	Valve Lifter Oil Filter
22	Valve Lifter Oil Filter Seal
23	Bolt
24	Bolt
25	Engine Coolant Air Bleed Pipe
26	Engine Coolant Air Bleed Pipe O-ring Seal
27	Engine Valley Cover
28	Gasket
29	Engine Block

Fig 2: Cylinder Head/Upper Engine

Courtesy of GENERAL MOTORS CORP.

Callout	Component Name
100	Engine Block
209	Valve Lifter - Non-Active Fuel Management
210	Valve Lifter Guide
211	Valve Lifter Guide Bolt
212	Valve Push Rod
213	Valve Rocker Arm
214	Valve Rocker Arm Pivot Support Bolt
215	Valve Rocker Arm Pivot Support
216	Cylinder Head Core Hole Plug
217	Cylinder Head Gasket
218	Cylinder Head
219	Valve Lifter - Active Fuel Management
220	Cylinder Head Bolt - M10
221	Cylinder Head Bolt - M8
222	Valve Stem Oil Seal
223	Valve Spring
224	Valve Spring Cap
225	Valve Stem Key
226	Cylinder Head Core Hole Plug
227	Intake Valve
228	Exhaust Valve
229	Cylinder Head Plug
230	Cylinder Head Locating Pin
422	Oil Fill Tube O-Ring Seal
423	Oil Fill Tube
424	Oil Fill Cap
450	Oil Fill Cap O-Ring Seal
504	Valve Rocker Arm Cover Gasket
504	Valve Rocker Arm Cover Gasket
505	Valve Rocker Arm Cover
505	Valve Rocker Arm Cover
516	Valve Rocker Arm Cover Bolt
600	Exhaust Manifold
601	Exhaust Manifold Gasket
602	Exhaust Manifold Flange Bolt
603	Exhaust Manifold Heat Shield
604	Exhaust Manifold Heat Shield Bolt
700	Positive Crankcase Ventilation (PCV) Hose - Fresh Air
716	PCV Hose - Dirty Air
719	Ignition Coil Bracket
720	Ignition Coil Bracket Bolt
721	Ignition Coil Wire Harness Assembly
722	Ignition Coil
723	Ignition Coil Bolt
724	Spark Plug Wire
725	Engine Coolant Temperature Sensor
726	Spark Plug

Fig 3: Front of Engine

Courtesy of GENERAL MOTORS CORP.

Callout	Component Name
100	Engine Block
138	Crankshaft Balancer
139	Crankshaft Balancer Bolt
140	Crankshaft Front Oil Seal
200	Camshaft
201	Camshaft Bearing
202	Camshaft Sprocket Locating Pin
203	Camshaft Retainer
204	Camshaft Retainer Bolt
207	Crankshaft Sprocket
208	Timing Chain
231	Timing Chain Tensioner Bolt
232	Timing Chain Tensioner
234	Camshaft Position (CMP) Actuator Solenoid Valve
235	CMP Actuator
300	Water Pump
301	Water Pump Bolt
302	Water Pump Inlet Bolt
303	Water Pump Inlet
305	Engine Coolant Thermostat
306	Water Pump Gasket
408	Bolt
409	Oil Pump Housing Cover
410	Oil Pump Vane Ring
410	Oil Pump Vane Ring
411	Oil Pump Bolt
412	Oil Pump Slide
413	Oil Pump Housing
414	Oil Pump Slide Seal
415	Oil Pump Slide Seal
416	Oil Pump Slide Spring
417	Oil Level Indicator O-Ring Seal
418	Oil Level Indicator
419	Oil Level Indicator Tube Bolt
420	Oil Level Indicator Tube
421	O-Ring
456	Oil Pump Rotor
457	Oil Pump Vane
458	Oil Pump Housing
501	Engine Front Cover Bolt
502	Engine Front Cover
503	Engine Front Cover Gasket
703	CMP Sensor
704	CMP Sensor O-Ring Seal
705	CMP Sensor Bolt
737	CMP Sensor Wire Harness Assembly
738	CMP Sensor Wire Harness Assembly Bolt
738	CMP Sensor Wire Harness Assembly Bolt
751	CMP Actuator Hub Cover Bolt
752	CMP Actuator Magnet
753	CMP Actuator Magnet Gasket

Fig 4: Rear of Engine

Courtesy of GENERAL MOTORS CORP.

Callout	Component Name
100	Engine Block
132	Flex Plate - Automatic Transmission
133	Flywheel Bolt
141	Crankshaft Rear Oil Seal
517	Crankshaft Rear Oil Seal Housing Bolt
518	Crankshaft Rear Oil Seal Housing
519	Crankshaft Rear Oil Seal Housing Gasket

Fig 5: Lower Engine Assembly

Courtesy of GENERAL MOTORS CORP.

Callout	Component Name
1	Engine Block
2	Piston Pin Retainer
3	Piston Pin
4	Piston Ring Set
5	Piston
6	Connecting Rod
7	Connecting Rod Bearing
8	Connecting Rod Cap
9	Connecting Rod Bolt
10	Crankshaft Bearing
11	Crankshaft Thrust Bearing
12	Crankshaft Balancer Key
13	Crankshaft
14	Crankshaft Bearing Cap Stud - M10
15	Crankshaft Bearing Cap Bolt - M10
16	Crankshaft Bearing Cap
17	Crankshaft Bearing Cap Bolt - M8
18	Crankshaft Oil Deflector
19	Crankshaft Oil Deflector Nut
20	Oil Pan Gasket
21	Oil Pan Baffle Bolt
22	Oil Pan Baffle
23	Oil Pan Closeout Cover
24	Oil Pan Closeout Cover Bolt
25	Active Fuel Management Oil Pressure Relief Valve
26	Oil Pan Cover Gasket
27	Oil Pan Cover
28	Oil Pan Cover Bolt
29	Oil Filter Fitting
30	Oil Filter
31	Oil Pan Bolt
32	Oil Pan Bolt
33	Oil Pan
34	Oil Pan Drain Plug
35	Oil Pan Closeout Cover
36	Oil Pan Closeout Cover Bolt
37	Oil Pump Suction Pipe Nut
38	Oil Pump Suction Pipe Bolt
39	Oil Pump Screen Assembly with Oil Pump Suction Pipe
40	Oil Pump O-Ring Seal

Fig 6: Engine Block Plugs/Sensors

Courtesy of GENERAL MOTORS CORP.

Callout	Component Name
100	Engine Block
100	Engine Block
101	Oil Gallery Plug - Front
110	O-Ring
111	Oil Gallery Plug - Rear
112	Oil Gallery Plug - Side
113	Washer
114	Engine Coolant Heater
115	Washer
116	Oil Gallery Plug - Side
117	Washer
130	Transmission Housing Locating Pin
145	Washer
146	Engine Block Coolant Drain Hole Plug
701	Crankshaft Position (CKP) Sensor
702	O-Ring
718	Knock Sensor
718	Knock Sensor
739	Bolt
739	Bolt
750	CKP Sensor Bolt

Fig 7: Oil Pump Assembly

Courtesy of GENERAL MOTORS CORP.

Callout	Component Name
408	Bolt
409	Oil Pump Housing Cover
410	Oil Pump Vane Ring
410	Oil Pump Vane Ring
412	Oil Pump Slide
413	Oil Pump Housing
414	Oil Pump Slide Seal
415	Oil Pump Slide Seal
416	Oil Pump Slide Spring
456	Oil Pump Rotor
457	Oil Pump Vane
458	Oil Pump Housing