LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2006 >> Sierra 1500 HD, RWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1622 (Front Drive Axle) >> Diagnostic Information and Procedures >> Four-Wheel Drive Does Not Disengage

Four-Wheel Drive Does Not Disengage

WARNING: This page is about a different car, the 2010 GMC Sierra, 2010 GMC Cab & Chassis Sierra, 2010 Chevrolet Silverado, and 2010 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
IMPORTANT: Before performing the following diagnostic procedure, ensure that all electrical diagnostic procedures have been performed and there are no DTCs.
Step Action Yes No
1 Confirm operation of system. Refer to Front Drive Axle Description and Operation .
Is the system operating properly?		 Test the system Go to Step 2 
2
  1. Raise the vehicle. Refer to Lifting and Jacking the Vehicle .
  2. Remove the actuator motor. Refer to Front Drive Axle Actuator Replacement .
  3. Using a brass drift, apply pressure to the clutch fork.
  4. Turn the right wheel to align the clutch gears.
While turning the right wheel, does the left wheel turn in the opposite direction?		 Test the system Go to Step 3 
3
  1. Remove the inner axle shaft and housing assembly. Refer to Front Drive Axle Inner Shaft and Inner Shaft Housing Replacement (8.25 F4WD Axle)  or Front Drive Axle Inner Shaft and Inner Shaft Housing Replacement (8.25 S4WD and 9.25 Axles) .
  2. Inspect the following:
    • Clutch Fork
    • Clutch Sleeve
    • Clutch Gear
    • Clutch Return Spring

      Repair as needed.

Did you complete the repair?		 Test the system System OK
scientia non olet · About LEMON Manuals