LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2006 >> Sierra 1500 HD, RWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1555 (Battery, Charging System And Starting System - Non-Hybrid) >> Repair Instructions >> Starter Replacement (6.6L) >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2010 GMC Sierra, 2010 GMC Cab & Chassis Sierra, 2010 Chevrolet Silverado, and 2010 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: View Of Starter Motor & Bolts
    GM1874075Courtesy of GENERAL MOTORS CORP.
  1. Install the starter motor.
    2. CAUTION: Refer to Fastener Caution .
  2. Install the starter motor bolts (1).

    Tighten:  Tighten the bolts to 85 N.m (63 lb ft).

  3. Install the exhaust manifold-to-catalytic converter pipe. Refer to Catalytic Converter Replacement (LY6 with Exhaust Flange) or Catalytic Converter Replacement (L9H with Exhaust Flange) or Catalytic Converter Replacement (Gen IV Engines with Exhaust Clamp) or Catalytic Converter Replacement (LFA with Exhaust Clamp) or Catalytic Converter Replacement (LMM) .
    4. Fig 2: View Of Starter Solenoid Cable Terminal, Bracket & Bolts
    GM1874038Courtesy of GENERAL MOTORS CORP.
  4. Install the engine wiring harness lead (2) to the starter motor.
  5. Install the engine wiring harness lead nut (3).

    Tighten:  Tighten the nut to 3.4 N.m (30 lb in).

    6. Fig 3: View Of Starter Solenoid Cable & Components
    GM1874037Courtesy of GENERAL MOTORS CORP.
  6. Install the starter solenoid cable (7) to the starter.
  7. Install the starter solenoid cable nut (6) to the starter.

    Tighten:  Tighten the nut to 9 N.m (80 lb in).

  8. Install the wheelhouse liner. Refer to Front Wheelhouse Liner Replacement - Right Side (Chevrolet) or Front Wheelhouse Liner Replacement - Right Side (GMC) .
  9. Connect the negative battery cable. Refer to Battery Negative Cable Disconnection and Connection (Single Battery)  or Battery Negative Cable Disconnection and Connection (Dual Batteries)  or Battery Negative Cable Disconnection and Connection (Auxiliary Battery) .
scientia non olet · About LEMON Manuals