LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2006 >> Sierra 1500 HD, RWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1292 (Sunroof System) >> Repair Instructions >> Sunroof Housing Drain Gutter Replacement (Extended Cab) >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2009 GMC Sierra, 2009 GMC Cab & Chassis Sierra, 2009 Chevrolet Silverado, and 2009 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: View Of Water Gutter & Retainers
    GM1825238Courtesy of GENERAL MOTORS CORP.
  1. Position the sunroof water gutter to the sunroof window track.
  2. Seat the retaining tabs (1) on the water gutter (3) into the slots (2) in the track, and push the water gutter forward until the retaining tabs lock into place.
  3. Ensure that all 6 tabs are secured.
    4. Fig 2: Identifying Screws & Water Gutter
    GM1825236Courtesy of GENERAL MOTORS CORP.
    CAUTION: Refer to Fastener Caution .
  4. Install the water gutter screws (1).

    Tighten:  Tighten the screws to 2 N.m (18 lb in).

  5. Install the sunroof module.
  6. Open the sunroof window to the fully open position.
  7. Install the air deflector. Refer to Sunroof Air Deflector Replacement (Extended Cab)  or Sunroof Air Deflector Replacement (Crew Cab) .
  8. Remove the tape from around the perimeter of the sunroof window.
  9. Verify that the sunroof is operating properly.
scientia non olet · About LEMON Manuals