Rattle, Clunk, or Shudder Noise from the Power Steering System
WARNING: This page is about a different car, the 2008 Cadillac CTS. However, it is still accessible from the selected car via links, so may be relevant.
| Step | Action | Yes | No |
|---|---|---|---|
| 1 | Did you review the Power Steering System General Description and perform the necessary inspections? | Go to Step 2 | Go to Symptoms - Power Steering System |
| 2 | Verify that a rattle, clunk or shudder noise is present. Is a rattle, clunk or shudder noise present? |
Go to Step 3 | System OK |
| 3 | Inspect the power steering hoses for proper routing and clearance. Is the routing or clearance of the power steering hoses incorrect? |
Go to Step 10 | Go to Step 4 |
| 4 | Inspect the accessory drive belt for cracking or excessive wear. Refer to Symptoms - Engine Mechanical
. Is the drive belt cracked or excessively worn? |
Go to Step 11 | Go to Step 5 |
| 5 | Inspect the power steering pump pulley for damage. Is the power steering pump pulley damaged? |
Go to Step 12 | Go to Step 6 |
| 6 | Inspect the power steering pump for the proper installation. Refer to Power Steering Pump Replacement . Is the power steering pump installation incorrect? |
Go to Step 13 | Go to Step 7 |
| 7 | Inspect the power steering gear for the proper installation. Refer to Steering Gear Replacement (with All Wheel Drive) or Steering Gear Replacement (with Rear Wheel Drive) . Is the power steering gear installation incorrect? |
Go to Step 14 | Go to Step 8 |
| 8 | Inspect the suspension. Is the suspension worn? |
Go to Step 15 | Go to Step 9 |
| 9 | Inspect the intermediate shaft. Is the intermediate shaft worn? |
Go to Step 16 | Go to Step 3 |
| 10 | Adjust or replace the power steering system hoses. Refer to the appropriate procedures:
Did you complete the repair? |
Go to Step 17 | - |
| 11 | Replace the drive belt. Refer to Air Conditioning Compressor and Power Steering Pump Belt Replacement
. Did you complete the repair? |
Go to Step 17 | - |
| 12 | Replace the power steering pump pulley. Refer to Power Steering Pump Pulley Replacement . Did you complete the repair? |
Go to Step 17 | - |
| 13 | Inspect the power steering pump for correct installation. Refer to Power Steering Pump Replacement . Did you complete the repair? |
Go to Step 17 | - |
| 14 | Inspect the power steering gear for correct installation. Refer to Steering Gear Replacement (with All Wheel Drive) or Steering Gear Replacement (with Rear Wheel Drive) . Did you complete the repair? |
Go to Step 17 | - |
| 15 | Replace the worn suspension components. Refer to Diagnostic Starting Point - Suspension General Diagnosis
. Did you complete the repair? |
Go to Step 17 | - |
| 16 | Replace the intermediate shaft. Refer to Upper Intermediate Steering Shaft Replacement
or Lower Intermediate Steering Shaft Replacement
. Did you complete the repair? |
Go to Step 17 | - |
| 17 | Operate the system in order to verify the repair. Did you correct the condition? |
System OK | Go to Step 3 |