LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 994 (Engine Mechanical - 6.6L (LLY)) >> Repair Instructions >> Off-Vehicle Repair Instructions >> Exhaust Manifold Installation - Right

Exhaust Manifold Installation - Right

WARNING: This page is about a different car, the 2004 GMC Sierra, 2004 GMC Cab & Chassis Sierra, 2004 Chevrolet Silverado, and 2004 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the exhaust manifold gasket.
  2. Install the exhaust manifold.
    3. Fig 1: View Of Right Exhaust Manifold & Gasket
    GM1336108Courtesy of GENERAL MOTORS CORP.
    NOTE: Refer to Fastener Notice in Cautions and Notices.
  3. Install the exhaust manifold bolts and nuts.

    Tighten:  Tighten the exhaust manifold bolts and nuts to 38 N.m (28 lb ft) in the proper sequence.

    4. Fig 2: Exhaust Manifold Bolts & Nuts Installation Sequence (Left Side Shown; Right Side Similar)
    G00310199Courtesy of GENERAL MOTORS CORP.
  4. Install the exhaust manifold heat shield.
  5. Install the exhaust manifold heat shield bolts.

    Tighten:  Tighten the exhaust manifold heat shield bolts to 10 N.m (89 lb in).

    6. Fig 3: View Of Exhaust Manifold Heat Shield (Right)
    GM1336106Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals