LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 982 (Heating, Ventilation And Air Conditioning - Gas) >> Repair Instructions >> Mode Door Replacement - Lower (Visteon) >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2004 GMC Sierra, 2004 GMC Cab & Chassis Sierra, 2004 Chevrolet Silverado, and 2004 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the mode door (1) to the air distribution housing (1).
    Fig 1: Mode Door (Visteon)
    GM826792Courtesy of GENERAL MOTORS CORP.
  2. Install the air distribution housing (1) to the HVAC module assembly (2).
    Fig 2: Removing/Installing Air Distribution Housing (Visteon)
    GM826798Courtesy of GENERAL MOTORS CORP.
    3. NOTE: Refer to Fastener Notice in Cautions and Notices.
  3. Install the screws to the air distribution housing (1).

    Tighten:  Tighten the screws to 2 N.m (18 lb in).

  4. Install the wiring harness to the air distribution housing (1).
    5. Fig 3: View Of Mode Actuator
    GM826791Courtesy of GENERAL MOTORS CORP.
  5. Connect the electrical connector (3) to the mode actuator (4).
  6. Install the screws to the mode actuator (4).
  7. Install the mode actuator (4) to the HVAC module assembly (1).
  8. Install the HVAC module assembly. Refer to HVAC Module Assembly Replacement .
scientia non olet · About LEMON Manuals