LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 978 (Parking Brake System) >> Repair Instructions >> Park Brake Cable Replacement - Right Rear (w/NYS) >> Installation Procedure

Installation Procedure

WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2004 GMC Sierra, 2004 GMC Cab & Chassis Sierra, 2004 Chevrolet Silverado, 2004 Chevrolet Cab & Chassis Silverado, and 2003 GMC Sierra. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the new brake cable (2) into the rear brake cable mounting bracket (3) by pushing the cable into place until the locking tabs (1) snap into place.
    2. Fig 1: Locking Tabs, Park Brake Cable & Mounting Bracket - Right Rear (w/NYS)
    GM791822Courtesy of GENERAL MOTORS CORP.
  2. Install the park brake cable to the lever.
    3. Fig 2: View Of Park Brake Cable To Park Brake Actuator Lever
    GM791352Courtesy of GENERAL MOTORS CORP.
    NOTE: Refer to Fastener Notice in Cautions and Notices.
  3. Install the rear park brake cable bracket bolt.

    Tighten:  Tighten the rear park brake cable bracket bolt to 61 N.m (45 lb ft).

    4. Fig 3: Rear Park Brake Cable Bracket Bolt - Right Rear (w/NYS)
    GM791768Courtesy of GENERAL MOTORS CORP.
  4. Install the park brake cable to the differential clip.
  5. Install the park brake cable bolt to the rear axle clip.

    Tighten:  Tighten the park brake cable bolt to 25 N.m (18 lb ft).

    6. Fig 4: Installing Park Brake Cable To Differential & Rear Axle Clips - Right Rear (w/NYS)
    GM366864Courtesy of GENERAL MOTORS CORP.
  6. Install the park brake cable taking care to correctly route the cable though the guides and the body mounts.
  7. Install the park brake cable into the mounting bracket until the locking tabs snap into place.
    8. Fig 5: View of Park Brake Cable & Mounting Bracket
    GM363839Courtesy of GENERAL MOTORS CORP.
  8. Pull down on the park brake cable in front of the equalizer and install the left park brake cable to the equalizer bar.
    9. Fig 6: Park Brake Cable & Equalizer - Right Rear (w/NYS)
    GM493216Courtesy of GENERAL MOTORS CORP.
  9. Remove the safety stands.
  10. Lower the vehicle.
scientia non olet · About LEMON Manuals