LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 97 (Starting System) >> Trouble Shooting >> Intermittent Or Poor Connections >> Round Wire Connectors

Round Wire Connectors

WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2002 GMC Savana Special, 2002 GMC Savana Camper Special, 2002 GMC Savana, 2002 Chevrolet RV Cutaway, and 2002 Chevrolet Cutaway. However, it is still accessible from the selected car via links, so may be relevant.

Follow the procedure to test terminal contact of Metri-Pack or 56 series terminals. Refer to the terminal repair kit or the instruction manual for terminal identification. Follow the procedure in order to test terminal contact.

  1. Separate the connector halves.
  2. Visually inspect the connector halves for contamination. Contamination may result in a White or Green build-up within the connector body or between terminals. This causes high terminal resistance, intermittent contact, or an open circuit. An underhood or underbody connector that shows signs of contamination should be replaced in its entirety: terminals, seals, and connector body.
  3. Using an equivalent male terminal from the terminal repair kit, test that the retention force is significantly different between a good terminal and a suspect terminal. Replace the female terminal in question.

scientia non olet · About LEMON Manuals