LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 951 (Engine Controls - 6.6L (LLY) (Introduction)) >> Repair Instructions >> Air Cleaner Outlet Duct Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2004 GMC Sierra, 2004 GMC Cab & Chassis Sierra, 2004 Chevrolet Silverado, and 2004 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
    IMPORTANT: The air cleaner outlet duct must be fully seated against the positive stop feature on the turbocharger inlet.
    NOTE: Refer to Fastener Notice in Cautions and Notices.
    Fig 1: View Of Air Cleaner Outlet Duct
    GM1480491Courtesy of GENERAL MOTORS CORP.
  1. Install the air cleaner outlet duct.
  2. Tighten the outlet duct clamps at the turbocharger and the MAF/IAT sensor.

    Tighten:  Tighten the clamps to 4 N.m (35 lb in).

scientia non olet · About LEMON Manuals