LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 939 (Manual Transmission -- ZF S6-650) >> Repair Instructions >> Transmission Mount Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2004 GMC Sierra and 2004 Chevrolet Silverado. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the rear transmission mount.
    NOTE: Refer to Fastener Notice in Cautions and Notices.
  2. Install the transmission mount bolts.

    Tighten:  Tighten the transmission mount bolts to 50 N.m (37 lb ft).

    Fig 1: Installing The Transmission Mount
    GM691715Courtesy of GENERAL MOTORS CORP.
  3. Lower the transmission.
  4. Install the transmission mount to crossmember nuts.

    Tighten:  Tighten the transmission mount to crossmember nuts to 54 N.m (40 lb ft).

  5. Lower the vehicle.
scientia non olet · About LEMON Manuals