SUZUKI (1995-04)

WARNING: This page does not describe the selected car, but rather 960 other vehicles, including the 2004 Toyota Tundra, 2004 Toyota Tacoma, 2004 Toyota Sienna, 2004 Toyota Sequoia, and 2004 Toyota RAV4. However, it is still accessible from the selected car via links, so may be relevant.

WARNING: Accidental air bag deployment is possible. Personal injury may result. Avoid area near steering wheel and instrument panel even if air bags have deployed. Dual-stage air bag modules may be present that could contain an undeployed stage. When disposing of a deployed dual-stage air bag, always treat it as a "live" module. See appropriate AIR BAG RESTRAINT SYSTEMS article.

APPLICATION - SUZUKI

Make/Model	Year	Location	Table
Aerio	2002-04	D-P	Suzuki-1
Esteem	1995-02	D-P	Suzuki-1
Forenza	2004	D-P2	Suzuki-2
Sidekick	1996-98	D-P	Suzuki-1
Swift	1995-01	D-P	Suzuki-1
Verona	2004	D-P2, SI	Suzuki-2
Vitara & Grand Vitara	1999-04	D-P	Suzuki-1
XL7	2004	D-P2	Suzuki-1
	2001-04	D-P	Suzuki-1
X90	1996-98	D-P	Suzuki-1

D-P: Driver's & Passenger's Side
D-P2: Driver's & Passenger's Side (Dual-Stage)
DS: Driver's Side
HI: Head Impact
KI: Knee Impact
SI: Side Impact
PS2: Passenger's Side (Dual-Stage)

Suzuki-1

Replace After Deployment

Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy)

Comments

Deployed air bag modules; Sensing & Diagnostic Module (SDM); Forward sensors (if equipped); Deployed seat belt pretensioners (if equipped);

AIR BAG warning light operation; Combination switch assembly & contact coil; Forward sensors⁽¹⁾; Instrument panel reinforcement; Knee bolsters; Seat belts & mounting points; SDM & SDM bracket; Steering column bracket; Steering column & shaft joints; Steering wheel; Wiring harness; Air bag module(s); Sensing & Diagnostic Module (SDM);

If any components are damaged or bent, they must be replaced.; DO NOT attempt SRS wiring harness repairs.;

⁽¹⁾	Swift and XL-7.

Suzuki-2

Replace After Deployment

Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy)

Comments

Deployed air bag modules; Clockspring; Sensing & Diagnostic Module (SDM)⁽¹⁾; SIR wiring harness; Deployed seat belt pretensioners (if equipped);

AIR BAG warning light operation; Instrument panel reinforcement; Knee bolsters; Seat belts & mounting points; SDM & SDM bracket; Steering column bracket; Steering column & shaft joints; Steering wheel; SIR wiring harness; Air bag module(s); Sensing & Diagnostic Module (SDM);

If any components are damaged or bent, they must be replaced.; DO NOT attempt SRS wiring harness repairs.;

⁽¹⁾	SDM can sustain 5 seat belt pretensioner deployments or one air bag module deployment before replacement is required