ISUZU (1990-04)

WARNING: This page does not describe the selected car, but rather 960 other vehicles, including the 2004 Toyota Tundra, 2004 Toyota Tacoma, 2004 Toyota Sienna, 2004 Toyota Sequoia, and 2004 Toyota RAV4. However, it is still accessible from the selected car via links, so may be relevant.

WARNING: Accidental air bag deployment is possible. Personal injury may result. Avoid area near steering wheel and instrument panel even if air bags have deployed. Dual-stage air bag modules may be present that could contain an undeployed stage. When disposing of a deployed dual-stage air bag, always treat it as a "live" module. See appropriate AIR BAG RESTRAINT SYSTEMS article.

APPLICATION - ISUZU

Make/Model	Year	Location	Table
Amigo	1999-00	D-P	Isuzu-2
Ascender	2003-04	D-P2, SI	Isuzu-7
Axiom	2002-04	D-P	Isuzu-6
Hombre	1996-00	D-P	Isuzu-1
Impulse	1990-92	DS	Isuzu-4
Oasis	1996-98	D-P	Isuzu-5
Rodeo	1996-04	D-P	Isuzu-2
	1995 1-2	D-P	Isuzu-2
Rodeo Sport	2001-03	D-P	Isuzu-2
Stylus	1991-93	DS	Isuzu-4
Trooper	1996-02	D-P	Isuzu-2
	1995	D-P	Isuzu-3
VehiCROSS	1999-01	D-P	Isuzu-2

D-P: Driver's & Passenger's Side
D-P2: Driver's & Passenger's Side (Dual-Stage)
DS: Driver's Side
HI: Head Impact
KI: Knee Impact
SI: Side Impact
PS2: Passenger's Side (Dual-Stage)

Isuzu-1

Replace After Deployment	Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy)	Comments
Deployed air bag modules; Sensors in area of accident damage;	Instrument panel braces; Instrument panel steering column reinforcement plate; Knee bolster; Seat belts & mounting points; Sensors in area of accident damage; SRS coil assembly; Steering column;	Any sensor that the Diagnostic Energy Reserve Module (DERM) indicates as bad must be replaced.; If any components are damaged or bent, they must be replaced.; SRS wiring can be repaired following manufacturer's instructions.;

Isuzu-2

Replace After Deployment

Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy)

Comments

Deployed air bag modules; Sensing & Diagnostic Module (SDM);

Instrument panel braces; Instrument panel steering column reinforcement plate; Knee bolster & mounting points; Seat belts & mounting points; SRS coil assembly; Passenger-side air bag door⁽¹⁾; Steering column; Wiring harnesses;

If any components are damaged or bent, they must be replaced.; DO NOT attempt wiring harness repairs. Replace harness.;

⁽¹⁾	If equipped.

Isuzu-3

Replace After Deployment	Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy)	Comments
Deployed air bag modules; All sensors;	SRS coil assembly; Instrument panel steering column reinforcement plate; Instrument panel braces; Knee bolsters; Seat belts & mounting points; Sensors in area of accident damage; Steering column;	If any components are damaged or bent, they must be replaced.;

Isuzu-4

Replace After Deployment	Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy)	Comments
Deployed air bag modules; All sensors;	Arming sensor; Coil assembly; Diagnostic Energy Module (DERM); Forward sensor; Instrument panel steering column reinforcement plate; Knee pad; Passenger compartment sensor; Steering column; Wiring harness & brackets; Seat belts & mounting points;	If any components are damaged or bent, they must be replaced.;

Isuzu-5

Replace After Deployment	Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy)	Comments
Deployed air bag modules; Deployed seat belt pretensioners (if equipped); SRS control unit;	Cable reel; Dash sensors (1991-94); Seat belts & mounting points; SRS control unit; SRS wiring harnesses;	If any components are damaged or bent, they must be replaced.; DO NOT attempt SRS wiring repairs. If SRS wiring or harness connectors are faulty, replace faulty wiring harness.; After vehicle is repaired, ensure AIR BAG warning light is functioning properly.;

Isuzu-6

Replace After Deployment	Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy)	Comments
Deployed air bag modules; Sensing & Diagnostic Module (SDM);	Air bag modules; SRS coil assembly; SRS wiring harnesses; Steering wheel; Steering column; Knee bolster & mounting points; Instrument panel steering column reinforcement plate; Instrument panel braces & mounting points; Driver & passenger seats; Seat belts & mounting points; SDM;	If any components are damaged or bent, they must be replaced.; DO NOT attempt SRS wiring repairs. If SRS wiring or harness connectors are faulty, replace faulty wiring harness.;

Isuzu-7

Replace After Deployment

Inspect & If Damaged Replace Component (Even If Air Bag Did Not Deploy)

Comments

Deployed air bag modules; SRS coil assembly; Electronic Frontal Sensors (EFS)⁽¹⁾; Side Impact Sensors (SIS)⁽²⁾; Sensing & Diagnostic Module (SDM);

Air bag modules; SRS coil assembly; SRS wiring harnesses; Steering wheel; Steering column; Knee bolster & mounting points; Instrument panel cross car beam; Instrument panel braces & mounting points; Driver & passenger seats & mounting points; Seat belts & mounting points; SDM;

If any components are damaged or bent, they must be replaced.; DO NOT attempt SRS wiring repairs. If SRS wiring or harness connectors are faulty, replace faulty wiring harness.;

⁽¹⁾	Following frontal air bag deployment

⁽²⁾	Following deployment of side impact air bag module, on side of impact.