Brake Fluid & Brake Fluid Handling

WARNING: This page is about a different car, the 2002 GMC Safari and 2002 Chevrolet Astro. However, it is still accessible from the selected car via links, so may be relevant.

CAUTION: Brake fluid may irritate eyes and skin. In case of contact, take the following actions:

Eye contact-rinse thoroughly with water.
Skin contact-wash with soap and water.
If ingested-consult a physician immediately.

CAUTION: Use only Delco Supreme 11, GM P/N 12377967 (Canadian PIN 992667), or equivalent DOT 3 brake fluid from a clean, sealed container. Do not use fluid from an open container that may be contaminated with water. Improper or contaminated fluid could result in damage to components, or loss of braking, with possible injury.

NOTE: When filling the master cylinder, use only Delco Supreme 11, GM P/N 12377967 (Canadian P/N 992667), or equivalent DOT 3 brake fluid. Do not use a container which has been used for petroleum based fluids, or a container which is wet with water. Petroleum based fluids will cause swelling and distortion of rubber parts in the hydraulic brake system, and water will mix with brake fluid, lowering the boiling point. Keep all fluid containers capped to prevent contamination.

NOTE: Brake fluid will damage electrical connections and painted surfaces. Use shop cloths, suitable W containers, and fender covers to prevent brake fluid from contacting these areas. Always re-seal and wipe off brake fluid containers to prevent spills.

NOTE: Avoid spilling brake fluid on any of the vehicle's painted surfaces, wiring, cables or electrical connectors. Brake fluid will damage paint and electrical connections. If any fluid is spilled on the vehicle, immediately flush the area with water to minimize the potential for damage.

NOTE: Power steering fluid, engine oil, brake fluid, or any mineral based fluids cannot be mixed. If brake seals contact power steering fluid or steering seals contact brake fluid, seal damage will result.

Important:

Do not reuse the brake fluid collected during the hydraulic brake system bleeding.
Always store brake fluid in a closed container.
Reseal brake fluid containers immediately after use.
Do not use brake fluid left in an open container.
Do not use brake fluid left in an improperly sealed container.
Do not use the following fluids in the hydraulic k brake system:
- Power steering fluid
- Automatic transmission fluid
- DOT 5 silicone hydraulic brake fluid