LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 708 (Engine Mechanical - 3.1L (On-Vehicle)) >> Repair Instructions >> Oil Pump Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2002 Chevrolet Malibu. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the oil pump.
  2. Install the drive shaft extension.
  3. Engage the drive shaft extension into the drive gear.
    CAUTION: Refer to FASTENER NOTICE in Cautions and Notices.
  4. Install the pump to the rear bearing cap bolt.

    Tighten 

    Tighten the oil pump nut to 41 N.m (30 lb ft).

  5. Install the oil pan. Refer to Oil Pan Replacement  .
    Fig 1: Installing Oil Pump
    G01810961Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals