LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 632 (Battery, Charging System And Starting System) >> Repair Instructions >> Battery Positive Cable Replacement - Battery Relay to Starter - Auxiliary >> Removal Procedure

Removal Procedure

WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2002 GMC Yukon XL, 2002 GMC Yukon, 2002 Chevrolet Tahoe, 2002 Chevrolet Suburban, and 2002 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.
CAUTION: Refer to BATTERY DISCONNECT CAUTION .
    Fig 1: View of Battery Ground Negative Cable
    GM662415Courtesy of GENERAL MOTORS CORP.
  1. Disconnect the auxiliary negative battery cable. Refer to Battery Negative Cable Disconnect/Connect Procedure (Single Battery)  or Battery Negative Cable Disconnect/Connect Procedure (Auxiliary Battery) .
    2. Fig 2: View of Auxiliary Battery Positive Cable
    GM662684Courtesy of GENERAL MOTORS CORP.
  2. Reposition the boot to expose the stud.
  3. Remove the auxiliary battery positive cable nut.
  4. Remove the auxiliary battery positive cable to the auxiliary battery relay.
  5. Remove the auxiliary battery positive cable clip from the auxiliary battery tray.
  6. Raise and suitably support the vehicle. Refer to LIFTING & JACKING THE VEHICLE .
    7. Fig 3: View of Auxiliary Battery Positive Cable Clip Bolt
    GM662688Courtesy of GENERAL MOTORS CORP.
  7. Remove the auxiliary battery positive cable clip bolt from the frame.
    8. Fig 4: View of Positive Cable Nut
    GM662690Courtesy of GENERAL MOTORS CORP.
  8. Remove the positive cable nut.
  9. Remove the positive cable from the starter.
  10. Remove the auxiliary positive battery cable from the starter.
  11. Remove the auxiliary positive battery cable.
scientia non olet · About LEMON Manuals