LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 631 (Body Rear End) >> Repair Instructions >> Pressure Relief Valve Replacement (Avalanche/Escalade Ext) >> Removal Procedure

Removal Procedure

WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2002 GMC Yukon XL, 2002 GMC Yukon, 2002 Chevrolet Tahoe, 2002 Chevrolet Suburban, and 2002 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.
  1. Lower the end gate.
  2. Remove the rear compartment cover assembly(s).
  3. Remove the cargo box bridge center panel. Refer to PANEL REPLACEMENT - CARGO BOX BRIDGE CENTER (AVALANCHE) or PANEL REPLACEMENT - CARGO BOX BRIDGE CENTER (ESCALADE EXT) .
  4. Remove the rear side drain duct deflector. Refer to DEFLECTOR REPLACEMENT - BODY SIDE REAR DRAIN .
  5. Remove the cargo box bridge side inner panel. Refer to PANEL REPLACEMENT - CARGO BOX BRIDGE SIDE INNER (AVALANCHE/EXT) .
  6. Remove the cargo box bridge side outer panel. Refer to PANEL REPLACEMENT - CARGO BOX BRIDGE SIDE OUTER (AVALANCHE) .
    7. Fig 1: Pressure Relief Valve (Avalanche/Escalade Ext)
    GM800702Courtesy of GENERAL MOTORS CORP.
  7. Using a flat-bladed tool, carefully pry the valve loose.
scientia non olet · About LEMON Manuals