LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 568 (Body Rear End) >> Repair Instructions >> Lock Striker Replacement - Lower >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2002 GMC Savana Special, 2002 GMC Savana Camper Special, 2002 GMC Savana, and 2002 Chevrolet Chevy Express. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the rear door lower striker (1) to the floor panel.
    CAUTION: Use the correct fastener in the correct location. Replacement fasteners must be the correct part number for that application. Fasteners requiring replacement or fasteners requiring the use of thread locking compound or sealant are identified in the service procedure. Do not use paints, lubricants, or corrosion inhibitors on fasteners or fastener joint surfaces unless specified. These coatings affect fastener torque and joint clamping force and may damage the fastener. Use the correct tightening sequence and specifications when installing fasteners in order to avoid damage to parts and systems.
  2. Install the rear door lower striker bolts in order to retain the rear door lower striker (1) to the floor panel.

Tighten 

Tighten the rear door lower striker bolts to 10 N.m (89 lb in).

Fig 1: Installing Lower Lock Striker
G01737431Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals