LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 269 (Door System, Mirror System & Window System) >> Repair Instructions >> Window Replacement - Rear Door Stationary >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2002 Buick Regal and 2002 Buick Century. However, it is still accessible from the selected car via links, so may be relevant.
  1. Position the window in the full down position.
  2. Remove the trim panel. Refer to Trim Panel Replacement - Side Rear Door .
  3. Remove the rear door water deflector. Refer to Water Deflector Replacement - Rear Door .
  4. Remove the inner sealing strip. Refer to Sealing Strip Replacement - Rear Door Window Belt Inner .
  5. Remove the outer belt sealing strip. Refer to Sealing Strip Replacement - Rear Door Window Belt Outer .
  6. Lower the rear door window as low as possible in the door opening and remove the two screws attaching it to the regulator.
  7. Slide the window glass down to the bottom of the door while keeping it in the front weatherstrip channel.
  8. Partially remove the rear door window weatherstrip from the channel between the door glass and the stationary window and part way across the top of the window.
  9. Remove the door stationary window screws.
    10. Fig 1: Identifying Door Stationary Window Screws
    G01755901Courtesy of GENERAL MOTORS CORP.
  10. Remove the door stationary window bolt.
  11. Remove the rear door stationary window channel bolt.
  12. Rotate the window foreword and remove it from the rear door.
    Fig 2: Identifying Rear Door Stationary Window Channel Bolt
    G01755902Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals