LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1619 (Automatic Transmission - 4T45-E - Removal & Installation, Service, Overhaul, Troubleshooting & Diagnosis) >> On-Vehicle Repair Instructions >> Transmission Fluid Cooler Hose Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2009 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
    CAUTION: Allow sufficient clearance around the transaxle oil cooler pipes and around the hoses to prevent damage or wear which may cause fluid loss.
  1. Remove the battery box. Refer to Battery Tray Replacement (HP7) .
    2. Fig 1: Removing/Installing Upper Transaxle Oil Cooler Pipes Fitting At Radiator
    GM1471451Courtesy of GENERAL MOTORS CORP.
  2. Remove the upper transaxle oil cooler pipe fitting at the radiator.
  3. Raise and support the vehicle. Refer to Lifting and Jacking the Vehicle .
  4. Position a drain pan under the transaxle cooler pipes.
  5. Remove the transaxle oil cooler pipe retaining nut from the transaxle.
  6. Remove the transaxle oil cooler pipe from the transaxle.
  7. Remove the lower transaxle oil cooler pipe fitting at the radiator.
  8. Remove the transaxle oil cooler pipe retaining clip from the radiator.
  9. Remove the transaxle oil cooler pipes from the vehicle.
scientia non olet · About LEMON Manuals