LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1584 (Engine Mechanical - 2.4L (Lat)) >> Diagnostic Information and Procedures >> Crankcase Ventilation System Inspection/Diagnosis

Crankcase Ventilation System Inspection/Diagnosis

WARNING: This page is about a different car, the 2007 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
  1. Disconnect the positive crankcase ventilation (PCV) hose.
  2. Start the engine.
  3. Check for vacuum at the PCV hose. If there is no vacuum, inspect for a plugged hose or manifold port. Inspect for a hose that collapses when blocked with vacuum applied. Replace the plugged or the deteriorated hoses.
  4. Allow the engine to idle at normal operating temperature.
  5. Remove the engine oil level indicator. Install a vacuum gage into the indicator tube opening.
  6. Block off the PCV system fresh air intake passage.
  7. Run the engine at 1,500 RPM for 30 seconds, then read the vacuum gage while engine is running at 1,500 RPM.
    • If vacuum is present, the crankcase ventilation system is functioning properly.
    • If no vacuum is indicated, the engine may not be sealed and is drawing in outside air. Check the valve covers, the oil pan gasket, or other sealing areas for leaks.
    • If the vacuum gage registers a pressure, or if the vacuum gage is pushed out of indicator tube, check for a plugged PCV port, a plugged hose, or excessive engine blow-by.
scientia non olet · About LEMON Manuals