LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1537 (Automatic Transaxle - 4T45-E - Introduction (2 Of 2)) >> Repair Instructions >> Repair Instructions - Off Vehicle >> Transmission Fluid Auxiliary Pump Removal (L4 Hybrid Only)

Transmission Fluid Auxiliary Pump Removal (L4 Hybrid Only)

WARNING: This page is about a different car, the 2007 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: View Of Transmission Fluid Auxiliary Pump And Components
    GM1776839Courtesy of GENERAL MOTORS CORP.
    NOTE: Use care to restrain the check valve when removing the outlet pipe. Restrain while the nut is loosened or damage may occur.
  1. Hold the check valve (227) in its assembled position with a wrench and loosen the outlet pipe (229) nut from the check valve (227).
  2. Remove the upper suction pipe, M8 x 1.25 x 25 mm bolt (132) from the auxiliary pump (225).
  3. Remove the 4 auxiliary pump, M8 x 1.25 x 30 mm bolts (131).
    4. NOTE: Do not bend the electrical connector or clip or damage may occur. The electrical connector and clip are one piece.
  4. Disconnect the electrical connector.
  5. Remove the complete auxiliary pump (225) and check valve (227) assembly.
  6. Remove the outlet pipe, M8 x 1.25 x 25 mm, Bolt (132) and outlet pipe (229) from the case assembly.
  7. Remove the lower suction pipe, M8 x 1.25 x 25 mm bolt (132) and suction pipe (231) from the case assembly.
scientia non olet · About LEMON Manuals