LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1536 (Automatic Transmission - 5AT - Introduction (2 Of 2)) >> Repair Instructions >> Repair Instructions - Off Vehicle >> Torque Converter Clutch Lock Up Pressure Control Solenoid Installation

Torque Converter Clutch Lock Up Pressure Control Solenoid Installation

WARNING: This page is about a different car, the 2007 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: Pressure Control Solenoid Fluid Feed Passage Tube & Transmission Case Hole
    GM1206284Courtesy of GENERAL MOTORS CORP.
  1. Install a 8 x 53 mm TCC apply pressure control solenoid fluid feed passage tube (11) with the filter end facing the transmission case hole (2).
  2. Fig 2: Measuring The Top Of Fluid Passage Tube To Machined Surface Of Transmission Case
    GM1206289Courtesy of GENERAL MOTORS CORP.
  3. Measure from the top of the 8 x 53 mm fluid passage tube (11) to the machined surface of the transmission case (31). This is the installed height (a) of the fluid passage tube (11).
  4. If the measurement between the top of the tube and the case machined surface is approximately 7 mm (0.3 in), the tube is correctly installed in the accumulator fluid passage port.
  5. If the measurement is greater than 7 mm (0.3 in), install the fluid passage tube again until it is correctly seated in the accumulator body.
  6. Fig 3: TCC Lock-Up Pressure Control Solenoid Fluid Apply Passage Pipe & Solenoid Gasket
    GM1347233Courtesy of GENERAL MOTORS CORP.
  7. Install a 8 x 36 mm TCC lock-up pressure control solenoid fluid apply passage pipe (10) with the filter end facing the transmission case.
  8. Install the following components into the transmission case:
    • A 8 x 25.2 mm TCC lock-up pressure control solenoid fluid apply passage pipe (13)
    • A new TCC apply pressure control solenoid gasket (12)
  9. Fig 4: TCC Apply Pressure Control Solenoid Assembly & Valve Bolts
    GM1347234Courtesy of GENERAL MOTORS CORP.
  10. Install both 7.7 x 2.3 mm clutch pressure control fluid passage pipe O-ring seals (9) over the fluid feed passage tubes.
  11. NOTE: Refer to Fastener Notice in Cautions and Notices.
    IMPORTANT: Do not damage any of the TCC lock-up pressure control fluid passage pipe O-ring seals (9) during installation.
  12. Install the TCC apply pressure control solenoid assembly (7).
  13. Install the 4 TCC pressure control solenoid valve M6 x 1.0 x 30 mm bolts (6).

    Tighten:  Tighten the bolts to 12 N.m (106 lb in).