LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1512 (Bolted Exterior Body Panels And Closures) >> Repair Instructions >> Rear Side Door Outer Panel Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2007 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: View Of Outer Door Panel
    GM929755Courtesy of GENERAL MOTORS CORP.
  1. If the panel is being replaced, Install the U-nuts.
  2. Install the outer door panel on the door structure.
    3. NOTE: Refer to Fastener Notice .
    Fig 2: Outer Door Panel Fasteners Tightening Sequence
    GM928897Courtesy of GENERAL MOTORS CORP.
  3. Install the outer door panel fasteners. Tighten in the sequence shown.

    Tighten:  Tighten the fasteners to 8 N.m (71 lb in).

  4. Install the rear outer belt sealing strip. Refer to Rear Door Window Belt Outer Sealing Strip Replacement .
  5. Install the rear outside door handle. Refer to Rear Side Door Outsider Handle Replacement .
scientia non olet · About LEMON Manuals