LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1512 (Bolted Exterior Body Panels And Closures) >> Repair Instructions >> Rear Side Door Hinge Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2007 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
    CAUTION: In order to prevent SIR deployment, personal injury, or unnecessary SIR system repairs, do not strike the door or the door pillar in the area of the side impact sensor (SIS). Turn OFF the ignition and remove the key when performing service in the area of the SIS.
    Fig 1: Removing/Installing Hinge Rear Door
    GM928797Courtesy of GENERAL MOTORS CORP.
  1. Mark around the hinge location with a soft marker for installation alignment purposes.
  2. Support the door.
  3. With the door fully latched on the striker, remove the hinge to door bolts.
  4. Remove the hinge to body bolts and remove the hinges one at a time.
scientia non olet · About LEMON Manuals