LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1512 (Bolted Exterior Body Panels And Closures) >> Repair Instructions >> Front Side Door Outer Panel Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2007 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: View Of Front Outer Door Panel
    GM929525Courtesy of GENERAL MOTORS CORP.
  1. If the panel is being replaced, Install the door lock cylinder bezel.
    2. Fig 2: Identifying U-Nut Locations
    GM897839Courtesy of GENERAL MOTORS CORP.
  2. If the panel is being replaced, Install the U-nuts.
  3. Install the outer door panel on the door structure.
    4. Fig 3: Installing Outer Door Panel Fasteners
    GM928910Courtesy of GENERAL MOTORS CORP.
    NOTE: Refer to Fastener Notice .
  4. Install the outer door panel fasteners. Tighten in the sequence shown.

    Tighten:  Tighten the fasteners to 8 N.m (71 lb in).

  5. Install the front outer belt sealing strip. Refer to Front Side Door Window Belt Outer Sealing Strip Replacement .
  6. Install the front outside door handle. Refer to Front Side Door Outside Handle Replacement .
  7. Install the front mirror. Refer to Mirror Replacement .
  8. Install the front door trim panel upper extension. Refer to Upper Extension Trim Panel Replacement .
scientia non olet · About LEMON Manuals