LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1427 (Body Rear End) >> Repair Instructions >> Fuel Filler Pocket Replacement >> Installation Procedure

Installation Procedure

WARNING: This page is about a different car, the 2002 Pontiac Grand Prix. However, it is still accessible from the selected car via links, so may be relevant.
  1. Install the fuel filler pocket to the quarter panel.
    NOTE: Refer to FASTENER NOTICE .
  2. Install the screws to the fuel filler pocket.

    Tighten 

    Tighten the fuel filler pocket screws to 2 N.m (18 lb in).

  3. Install the bolts to the fuel filler pocket at the fuel filler neck.

    Tighten 

    Tighten the fuel filler pocket to fuel filler neck bolts to 5 N.m (44 lb in).

  4. Install the rear bumper fascia splash shield. Refer to Rear Wheelhouse Liner Panel Replacement .
  5. Replace the fuel filler cap.
  6. Close the fuel filler door.
    Fig 1: Fuel Filler Pocket
    G01617494Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals