LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1417 (Power Sun Roof) >> Repair Instructions >> Luggage Carrier Replacement (Z-71) >> Removal Procedure

Removal Procedure

WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2002 GMC Yukon XL, 2002 GMC Yukon, 2002 Chevrolet Tahoe, 2002 Chevrolet Suburban, and 2002 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: Base Covers
    GM752873Courtesy of GENERAL MOTORS CORP.
  1. Remove the 2 inboard fasteners from the luggage carrier base covers.
  2. Remove the base covers.
  3. Remove the fasteners from the front bases.
    4. Fig 2: Fasteners & Cross Rail Assembly
    GM752870Courtesy of GENERAL MOTORS CORP.
  4. Remove the fasteners (1) from each side of the rear base.
  5. Remove the roller bar/rear cross rail assembly (3) from the vehicle.
  6. Remove the fasteners (4) from the side rail/rear base.
    7. Fig 3: Carrier
    GM752862Courtesy of GENERAL MOTORS CORP.
  7. With an assistant, pull gently back on the carrier (1) in order to release the carrier from the supports.
  8. With an assistant, lift the carrier assembly up and off the vehicle.
    9. Fig 4: Center Supports
    GM752867Courtesy of GENERAL MOTORS CORP.
  9. Remove the fasteners from the center supports.
  10. Remove the center supports with pads from the vehicle.
    11. Fig 5: Rear Base Fasteners
    GM752870Courtesy of GENERAL MOTORS CORP.
  11. Remove the rear base fasteners (2) from the vehicle.
  12. Remove the rear bases with pads from the vehicle.
scientia non olet · About LEMON Manuals