Torque Specifications: Van
WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2002 GMC Savana Special, 2002 GMC Savana Camper Special, 2002 GMC Savana, 2002 GMC C3500 HD, and 2002 Chevrolet RV Cutaway. However, it is still accessible from the selected car via links, so may be relevant.
TORQUE SPECIFICATIONS (VAN)
| Application | Ft. Lbs. (N.m) | |||
|---|---|---|---|---|
| Battery Negative Cable/Ground Strap To Engine Block Bolt | 18 (25) | |||
| Coolant Drain Plug | 18 (25) | |||
| Crankcase Position Sensor Mounting Bolt | 18 (25) | |||
| Driven Gear-To-Injection Pump Bolt | 18 (25) | |||
| Engine Coolant Temperature Sensor | 18 (25) | |||
| Engine Shut-Down Solenoid Fastener | 18 (25) | |||
| Engine Wiring Harness Bracket Bolt | 17 (23) | |||
| Exhaust Manifold Bolt | 26 (35) | |||
| Exhaust Pipe-To-Turbocharger Bolt | 16 (35) | |||
| Fuel Feed Pipe & Suction Pipe-To-Fuel Pump | 22 (30) | |||
| Fuel Manager/Filter-To-Frame Bolt | 18 (25) | |||
| Fuel Tank Bolt | 33 (45) | |||
| Glow Plug | 13 (17) | |||
| Glow Plug Relay Mounting Nut | ||||
| Federal | 31 (42) | |||
| California | 16 (22) | |||
| Heat Shroud Nut | 17 (23) | |||
| Injection Lines-To-Nozzle Fitting | 18 (25) | |||
| Injection Pump Flange Nut | 30 (40) | |||
| Injection Nozzle | 52 (70) | |||
| Intake Air Temperature Sensor | 18 (25) | |||
| Lower Intake Manifold Stud | 31 (42) | |||
| Oil Cooler Line Fitting | 55 (75) | |||
| Oil Fill Neck Nut | 17 (23) | |||
| Oil Filter Adapter Fitting | 20 (27) | |||
| Oil Gallery Plugs | 25 (34) | |||
| Oil Level Indicator Upper Tube Bracket Nut | 16 (22) | |||
| Oil Pan | ||||
| Except Rear 2 Bolts | (1) | |||
| Rear 2 Bolts | 17 (23) | |||
| Oil Pan Drain Plug | 18 (25) | |||
| Turbocharger Heat Shield Left Bolt | 22 (30) | |||
| Turbocharger Heat Shield Nut | 22 (30) | |||
| Turbocharger Heat Shield 2 Top & 2 Right Bolt | 16 (22) | |||
| Upper Intake Manifold-To-Intake Manifold Bolt | 17 (23) | |||
| Wastegate Activator Mounting Bolt | 17 (23) | |||
| INCH lbs. (Nm) | ||||
| Accelerator Position Pedal Mounting Bolt | 9 (1) | |||
| Air Cleaner Mounting Bolt | 97 (11) | |||
| Boost Sensor Mounting Bolt | 31 (3.5) | |||
| Crankshaft Depression Regulator Valve Clamp | 15 (1.7) | |||
| Exhaust Pipe Clamp | 90 (10) | |||
| Fuel Solenoid Driver Mounting Screw | 24 (2.75) | |||
| Fuel Tank Filler Neck Clamp | 22 (2.5) | |||
| Fuel Tank Strap Bolts (Cutaway Van) | 106 (12) | |||
| Glow Plug Feed Wire Nut | ||||
| Federal | 40 (4.5) | |||
| California | 40 (4.5) | |||
| Oil Level Indicator Lower Tube Bracket Bolt | 36 (4) | |||
| Upper Air Intake Duct Clamp | 35 (4) | |||
| Upper Intake Manifold Cover Bolt | 97 (11) | |||
| Wastegate Solenoid Bolt | 27 (3.5) | |||
|
||||