LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1356 (Battery) >> Repair Instructions >> Battery Positive Cable Replacement - Battery Relay to Starter - Auxiliary >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2003 GMC Sierra, 2003 GMC Cab & Chassis Sierra, 2003 Chevrolet Silverado, and 2003 Chevrolet Cab & Chassis Silverado. However, it is still accessible from the selected car via links, so may be relevant.
CAUTION: Refer to BATTERY DISCONNECT CAUTION .
  1. Disconnect the auxiliary battery negative cable. Refer to Battery Negative Cable Disconnect/Connect Procedure (Single Battery)  or Battery Negative Cable Disconnect/Connect Procedure (Auxiliary Battery) .
  2. Reposition the boot.
  3. Remove the auxiliary positive battery cable nut.
  4. Remove the auxiliary positive battery cable from the auxiliary relay.
  5. Remove the auxiliary positive battery cable clip from the battery tray.
  6. Raise and suitably support the vehicle. Refer to JACKING AND LIFTING .
    Fig 1: Remove Auxiliary Positive Battery Cable Nut
    G02109431Courtesy of GENERAL MOTORS CORP.
  7. Remove the auxiliary cable clip bolt from the frame.
    Fig 2: Remove Auxiliary Cable Clip Bolt
    G02109432Courtesy of GENERAL MOTORS CORP.
  8. Remove the starter lead nut.
  9. Remove the auxiliary positive battery cable from the starter stud.
  10. Remove the auxiliary positive battery cable.
    Fig 3: Remove Auxiliary Positive Battery Cable & Starter Lead Nut
    G02109433Courtesy of GENERAL MOTORS CORP.
scientia non olet · About LEMON Manuals