LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1353 (Engine Mechanical - 4.3L) >> Repair Instructions >> Off-Vehicle Repair Instructions >> Timing Chain and Sprockets Installation >> Tools Required

Tools Required

WARNING: This page is about a different car, the 2003 GMC Sierra and 2003 Chevrolet Silverado. However, it is still accessible from the selected car via links, so may be relevant.

J 5590  Pinion Bearing Race Installer-Rear

  1. Install the crankshaft balancer key into the crankshaft keyway.

    The crankshaft balancer key should be parallel to the crankshaft or with a slight incline.

    Fig 1: Installing Crankshaft Balancer Key
    G02106391Courtesy of GENERAL MOTORS CORP.
  2. Align the keyway of the crankshaft sprocket with the crankshaft balancer key.
    CAUTION: Refer to SAFETY GLASSES CAUTION .
  3. Use the J 5590  in order to install the crankshaft sprocket.
    Fig 2: Installing Crankshaft Sprocket Using J 5590
    G02106392Courtesy of GENERAL MOTORS CORP.
  4. Rotate the crankshaft until the crankshaft sprocket alignment mark is at the 12 o'clock position.
    IMPORTANT: Install the camshaft sprocket with the alignment mark at the 6 o'clock position.
  5. Install the camshaft sprocket and the camshaft timing chain.
    Fig 3: Installing Camshaft Sprocket & Timing Chain
    G02106393Courtesy of GENERAL MOTORS CORP.
  6. Look to ensure that the crankshaft sprocket is aligned at the 12 o'clock position and camshaft sprocket is aligned at the 6 o'clock position.
    Fig 4: Showing Correct Alignment For Crankshaft Sprocket & Camshaft Sprocket
    G02106394Courtesy of GENERAL MOTORS CORP.
    NOTE: Refer to FASTENER NOTICE .
    IMPORTANT: Do not use a hammer to install the camshaft sprocket onto the camshaft. To do so may dislodge the expansion cup plug, camshaft rear bearing hole.
  7. Install camshaft sprocket bolts.

    Tighten 

    Tighten the camshaft sprocket bolts to 25 N.m (18 lb ft).

    Fig 5: Installing Camshaft Sprocket Bolts
    G02106395Courtesy of GENERAL MOTORS CORP.
  8. Install the crankshaft position sensor reluctor ring.
    1. 8.1. Align the keyway on the crankshaft position sensor reluctor ring with the crankshaft balancer key in the crankshaft.
    2. 8.2. Use the J 5590  in order to push the crankshaft position sensor reluctor ring onto the crankshaft until completely seated against the crankshaft sprocket.
    Fig 6: Install Crankshaft Position Sensor Reluctor Ring Using J 5590
    G02106396Courtesy of GENERAL MOTORS CORP.