LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1292 (HVAC Systems - Automatic) >> Repair Instructions >> Air Temperature Actuator Replacement - Left >> Removal Procedure

Removal Procedure

WARNING: This page is about a different car, the 2004 Chevrolet Corvette. However, it is still accessible from the selected car via links, so may be relevant.
  1. Remove the front floor kick-up panel. Refer to Kick-Up Panel Replacement - Front Floor in Interior Trim.
  2. Remove the Bose module. Refer to Bose Module Replacement in Entertainment.
    3. Fig 1: Inside Air Temperature Sensor Aspirator Duct
    GM95661Courtesy of GENERAL MOTORS CORP.
  3. Disconnect the inside air temperature sensor aspirator duct.
    1. Depress the duct retaining tab and remove the duct from the ignition switch housing bracket.
    2. Use a twisting motion to release the duct from the duct muffler.
    4. Fig 2: Inside Air Temperature Sensor Aspirator Duct Muffler
    GM95644Courtesy of GENERAL MOTORS CORP.
  4. Remove the inside air temperature sensor aspirator duct muffler.

    Use a twisting motion to release the duct muffler.

    5. Fig 3: Locating Actuator Connector
    GM295297Courtesy of GENERAL MOTORS CORP.
  5. Disconnect the air temperature actuator electrical connector.
    6. Fig 4: Left Air Temperature Actuator Screws
    GM295301Courtesy of GENERAL MOTORS CORP.
  6. Remove the air temperature actuator screws.
  7. Remove the air temperature actuator.
scientia non olet · About LEMON Manuals