LEMON Manuals: Even more car manuals for everyone
Home >> GMC >> 2003 >> Safari Van Cargo, AWD >> Repair and Diagnosis >> External Pages >> Different car >> Section 1272 (Manual Transmission -- TREMEC 6-Speed) >> Repair Instructions >> Transmission Fluid Replacement >> Filling Procedure

Filling Procedure

WARNING: This page is about a different car, the 2004 Chevrolet Corvette. However, it is still accessible from the selected car via links, so may be relevant.
    Fig 1: Transmission Fluid Drain Plug
    GM71532Courtesy of GENERAL MOTORS CORP.
    NOTE: Refer to Fastener Notice in Cautions and Notices.
  1. Install the transmission fluid drain plug.

    Tighten:  Tighten the transmission fluid drain plug to 27 N.m (20 lb ft).

    2. Fig 2: Transmission Fluid Fill Plug Hole
    GM71531Courtesy of GENERAL MOTORS CORP.
  2. Clean away all dirt and debris from the transmission fluid fill plug area.
  3. Remove the fill plug.
  4. Fill the transmission with DEXRON®-III transmission fluid, until even with the bottom of the fill plug hole.
  5. Install the transmission fluid fill plug.

    Tighten:  Tighten the transmission fluid fill plug to 27 N.m (20 lb ft).

  6. Lower the vehicle.
scientia non olet · About LEMON Manuals